高级搜索

聚硅铝三十(PASC30)的制备及混凝效果

,  , 

downloadPDF

上一篇

下一篇

李诚成, 赵远, 叶长青. 聚硅铝三十(PASC30)的制备及混凝效果[J]. 环境工程学报, 2016, 10(3): 1116-1120. doi: 10.12030/j.cjee.20160318
引用本文: 李诚成, 赵远, 叶长青. 聚硅铝三十(PASC30)的制备及混凝效果[J]. 环境工程学报, 2016, 10(3): 1116-1120. doi: 10.12030/j.cjee.20160318
shu
Li Chengcheng, Zhao Yuan, Ye Changqing. Synthesis and coagulation performance of flocculants composed of polysilic acid and Al30(PASC30)[J]. Chinese Journal of Environmental Engineering, 2016, 10(3): 1116-1120. doi: 10.12030/j.cjee.20160318
Citation: Li Chengcheng, Zhao Yuan, Ye Changqing. Synthesis and coagulation performance of flocculants composed of polysilic acid and Al30(PASC30)[J]. Chinese Journal of Environmental Engineering, 2016, 10(3): 1116-1120. doi: 10.12030/j.cjee.20160318
shu

聚硅铝三十(PASC30)的制备及混凝效果

  • 1.

    常州大学环境与安全工程学院, 常州 213164

  • 2.

    南通大学公共卫生学院, 南通 226019

  • 基金项目:

    国家自然科学基金资助项目(50948055,51078348)

    江苏省六大人才高峰(JNHB-012)

    江苏省环境监测科研基金项目(1047)

  • 中图分类号: X703.5

Synthesis and coagulation performance of flocculants composed of polysilic acid and Al30(PASC30)

  • 1.

    School of Environment & Safety Engineering, Changzhou University, Changzhou 213164, China

  • 2.

    School of Public Health, Nantong University, Nantong 226019, China

  • Fund Project:

  • 摘要: 制备一种新型的复合聚硅铝三十(PASC30)类絮凝剂,采用Al-Ferron逐时络合比色法测定PASC30系列混凝剂的铝形态以Alc为主,含量均在65%以上。将PASC30系列混凝剂与AlCl3和PASC13混凝剂进行对比,采用混凝法处理腐殖酸-高岭土模拟废水,考察各混凝剂对废水的浊度、UV254、pH和Zeta电位的影响。结果表明, PASC30系列混凝剂表现出更出色的混凝效果,在低投加量时就能达到AlCl3和PASC13混凝剂高投加量时的混凝效果。PASC30系列混凝剂对废水的浊度和UV254的最佳去除率分别达到96%和80%以上。随着投加量增大,PASC30系列混凝剂的出水pH不断降低,但是变化范围很小。不同硅/铝比对PASC30的混凝效果也有一定的影响,但是影响不大。
    Abstract: A new type of flocculent composed of polysilic acid and Al30(PASC30)was synthesized. The aluminum speciation of PASC30 coagulants was determined using the Al-Ferron time-dependent complex-colorimetric method. The results indicated that the dominant speciation of PASC30 coagulant was Alc, accounting for more than 65%. Simulated humic acid/kaolin wastewater was used to compare the effect of treating PASC13 and AlCl13 with PASC30, by coagulation. Turbidity, UV254, pH, and zeta potential were herein considered influencing factors. The results showed that PASC30 coagulants possess better coagulation effect, with higher removal efficiency at low dosage. The best removal efficiency for turbidity and UV254 were 96% and 80%, respectively. As the dosage increased, pH in the effluent continued decreasing within a small range. Different ratios of silicon/aluminum had little influence on the coagulation efficiency of PASC30.
  • 加载中
  • [1] Duan Jinming, Gregory J. Coagulation by hydrolysing metal salts. Advances in Colloid and Interface Science, 2003, 100-102:475-502
    [2] 肖辉煌, 张盼月, 曾光明, 等. 多核聚合形态Al30混凝控制水中腐殖酸与残留铝的研究. 安全与环境学报, 2007, 7(4):16-19 Xiao Huihuang, Zhang Panyue, Zeng Guangming, et al. Ways to control humic acid and residual aluminum in water by means of coagulation with polynuclear species Al30. Journal of Safety and Environment, 2007, 7(4):16-19(in Chinese)
    [3] Ye Changqing, Wang Dongsheng, Shi Baoyou, et al. Formation and transformation of Al13 from freshly formed precipitate in partially neutralized Al (III) solution. Journal of Sol-Gel Science and Technology, 2007, 41(3):257-265
    [4] He Lili, Xu Xinyang. Polymeric aluminum ferric chloride calcium composite flocculant:Preparation, characteristics and coagulation performance//Proceedings of International Conference on Frontiers of Environment, Energy and Bioscience. Beijing, 2013:734-740
    [5] 曲久辉, 贺泓, 刘会娟. 典型环境微界面及其对污染物环境行为的影响. 环境科学学报, 2009, 29(1):2-10 Qu Jiuhui, He Hong, Liu Huijuan. Typical environmental micro-interfaces and its effect on environmental behaviors of pollutants. Acta Scientiae Circumstantiae, 2009, 29(1):2-10(in Chinese)
    [6] Van Benschoten J. E., Edzwald J. K. Chemical aspects of coagulation using aluminum salts-I. Hydrolytic reactions of alum and polyaluminum chloride. Water Research, 1990, 24(12):1519-1526
    [7] Xu Yi, Wang Dongsheng, Liu Hong, et al. Optimization of the separation and purification of Al13. Colloids and Surfaces A:Physicochemical and Engineering Aspects, 2003, 231(1-3):1-9
    [8] Allouche L., Corine G., Loiseau T., et al. Al30:A giant aluminum polycation. Angewandte Chemie International Edition, 2000, 39(3):511-514
    [9] Rowsell J., Nazar L. F. Speciation and thermal transformation in alumina sols:Structures of the polyhydroxyoxoaluminum cluster[Al30O8(OH)56(H2O)26]18+ and its δ-keggin moieté. Journal of the American Chemical Society, 2000, 122(15):3777-3778
    [10] Gao Baoyu, Chu Yongbao, Yue Qinyan, et al. Characterization and coagulation of a polyaluminum chloride (PAC) coagulant with high Al13 content. Journal of Environmental Management, 2005, 76(2):143-147
    [11] Chen Zhaoyang, Fan Bin, Peng Xianjia, et al. Evaluation of Al30 polynuclear species in polyaluminum solutions as coagulant for water treatment. Chemosphere, 2006, 64(6):912-918
    [12] 叶长青, 杨玉环, 石健. PACl-Al30絮凝剂研究现状和展望. 环境科学与技术, 2011, 34(S1):148-151 Ye Changqing, Yang Yuhuan, Shi Jian. Status and prospects on PACl-Al30 flocculant. Environmental Science & Technology, 2011, 34(S1):148-151(in Chinese)
    [13] 高宝玉, 岳钦艳, 王艳, 等. Al-ferron逐时络合比色法研究PACS中铝的水解聚合形态. 环境化学, 1996, 15(3):234-239 Gao Baoyu, Qiu Qinyan, Wang Yan, et al. Study on the aluminum species of pacs by using Al-ferron timed complex colorimetric method. Environmental Chemistry, 1996, 15(3):234-239(in Chinese)
    [14] 彭建雄, 薛安, 赵华章, 等. 以Al-Ferron逐时络合比色法研究有机硅铝复合絮凝剂中铝的形态分布. 环境科学, 2008, 29(9):2513-2517 Peng Jianxiong, Xue An, Zhao Huazhang, et al. Al species distribution of organic silicate aluminum hybrid flocculants by Al-ferron complexation timed spectrophotometric method. Environmental Science, 2008, 29(9):2513-2517(in Chinese)
    [15] 叶长青, 王小平, 朱奇, 等. Al-ferron逐时络合比色分光光度法分析Al30形态的研究. 南通大学学报(自然科学版), 2013, 12(3):53-58 Ye Changqing, Wang Xiaoping, Zhu Qi, et al. Study on Al30 speciation by Al-ferron complex timed colorimetric method. Journal of Nantong University (Natural Science Edition), 2013, 12(3):53-58(in Chinese)
    [16] 王趁义, 张彩华, 毕树平, 等. Al-ferron逐时络合比色光度法测定聚合铝溶液中Ala, Alb和Alc三种铝形态的时间界限研究. 光谱学与光谱分析, 2005, 25(2):252-256 Wang Chenyi, Zhang Caihua, Bi Shuping, et al. Assay of three kinds of aluminum fractions (Ala, Alb and Alc) in polynuclear aluminum solutions by Al-ferron timed spectrophotometry and demarcation of their time limits. Spectroscopy and Spectral Analysis, 2005, 25(2):252-256(in Chinese)
    [17] Gao Baoyu, Wang Yan, Yue Qinyan. The chemical species distribution of aluminum in composite flocculants prepared from polyaluminum chloride (PAC) and polydimethyldiallylammonium chloride (PDMDAAC). Acta Hydrochimica et Hydrobiologica, 2005, 33(4):365-371
    [18] Zhou Weizhi, Gao Baoyu, Yue Qinyan, et al. Al-ferron kinetics and quantitative calculation of Al (III) species in polyaluminum chloride coagulants. Colloids and Surfaces A:Physicochemical and Engineering Aspects, 2006, 278(1-3):235-240
    [19] Feng Chenghong, Tang Hongxiao, Wang Dongsheng. Differentiation of hydroxyl-aluminum species at lower OH/Al ratios by combination of 27Al NMR and ferron assay improved with kinetic resolution. Colloids and Surfaces A:Physicochemical and Engineering Aspects, 2007, 305(1-3):76-82
  • 加载中
WeChat 点击查看大图
计量
  • 文章访问数:  2339
  • HTML全文浏览数:  1790
  • PDF下载数:  486
  • 施引文献:  0
出版历程
  • 收稿日期:  2014-12-15
  • 刊出日期:  2016-03-18
李诚成, 赵远, 叶长青. 聚硅铝三十(PASC30)的制备及混凝效果[J]. 环境工程学报, 2016, 10(3): 1116-1120. doi: 10.12030/j.cjee.20160318
引用本文: 李诚成, 赵远, 叶长青. 聚硅铝三十(PASC30)的制备及混凝效果[J]. 环境工程学报, 2016, 10(3): 1116-1120. doi: 10.12030/j.cjee.20160318
shu
Li Chengcheng, Zhao Yuan, Ye Changqing. Synthesis and coagulation performance of flocculants composed of polysilic acid and Al30(PASC30)[J]. Chinese Journal of Environmental Engineering, 2016, 10(3): 1116-1120. doi: 10.12030/j.cjee.20160318
Citation: Li Chengcheng, Zhao Yuan, Ye Changqing. Synthesis and coagulation performance of flocculants composed of polysilic acid and Al30(PASC30)[J]. Chinese Journal of Environmental Engineering, 2016, 10(3): 1116-1120. doi: 10.12030/j.cjee.20160318
shu

聚硅铝三十(PASC30)的制备及混凝效果

  • 1. 常州大学环境与安全工程学院, 常州 213164
  • 2. 南通大学公共卫生学院, 南通 226019
  • 收稿日期:  2014-12-15
基金项目:

国家自然科学基金资助项目(50948055,51078348)

江苏省六大人才高峰(JNHB-012)

江苏省环境监测科研基金项目(1047)

摘要: 制备一种新型的复合聚硅铝三十(PASC30)类絮凝剂,采用Al-Ferron逐时络合比色法测定PASC30系列混凝剂的铝形态以Alc为主,含量均在65%以上。将PASC30系列混凝剂与AlCl3和PASC13混凝剂进行对比,采用混凝法处理腐殖酸-高岭土模拟废水,考察各混凝剂对废水的浊度、UV254、pH和Zeta电位的影响。结果表明, PASC30系列混凝剂表现出更出色的混凝效果,在低投加量时就能达到AlCl3和PASC13混凝剂高投加量时的混凝效果。PASC30系列混凝剂对废水的浊度和UV254的最佳去除率分别达到96%和80%以上。随着投加量增大,PASC30系列混凝剂的出水pH不断降低,但是变化范围很小。不同硅/铝比对PASC30的混凝效果也有一定的影响,但是影响不大。

English Abstract

    全文HTML

参考文献 (19)

返回顶部

目录

/

返回文章
返回

Copyright © 2019 中国科学院生态环境研究中心