高声能密度超声波破碎污泥细胞效能的研究

沈会山; 胡勇有; 王广华; 梁树焜; 何向明; 谢义忠; 李凌云

环境工程学报

高声能密度超声波破碎污泥细胞效能的研究

, , , , , ,

沈会山, 胡勇有, 王广华, 梁树焜, 何向明, 谢义忠, 李凌云. 高声能密度超声波破碎污泥细胞效能的研究[J]. 环境工程学报, 2011, 5(9): 2115-2119.

引用本文:

沈会山, 胡勇有, 王广华, 梁树焜, 何向明, 谢义忠, 李凌云. 高声能密度超声波破碎污泥细胞效能的研究[J]. 环境工程学报, 2011, 5(9): 2115-2119.

Shen Huishan, Hu Yongyou, Wang Guanghua, Liang Shukun, He Xiangming, Xie Yizhong, Li Lingyun. 5Disintegration of sludge cell by ultrasonic technique of high ultrasonic density[J]. Chinese Journal of Environmental Engineering, 2011, 5(9): 2115-2119.

Citation:

Shen Huishan, Hu Yongyou, Wang Guanghua, Liang Shukun, He Xiangming, Xie Yizhong, Li Lingyun. 5Disintegration of sludge cell by ultrasonic technique of high ultrasonic density[J]. Chinese Journal of Environmental Engineering, 2011, 5(9): 2115-2119.

高声能密度超声波破碎污泥细胞效能的研究

1.
华南理工大学环境科学与工程学院工业聚集区污染控制与生态修复教育部重点实验室，广州 510006；
2.华南理工大学制浆造纸工程国家重点实验室，广州 510640
3.
南海发展股份有限公司，南海 528200
基金项目:
广东省科技计划项目(2007A032302001)
中图分类号: X703.1

5Disintegration of sludge cell by ultrasonic technique of high ultrasonic density

1.
Key Laboratory of Pollution Control and Ecological Remediation for Industial Agglomeration Area，Ministry of Education， College of Environmental Science and Engineering，South China University of Technology， Guangzhou 510006， China；2.State Key Lab oratory
3.
Nanhai Development Company Limited， Nanhai 528200， Guangdong， China
Fund Project:

摘要: 采用超声波在较高声能密度下处理SBR的剩余污泥，主要考察了含固率、声能密度和作用时间对污泥细胞破碎效果的影响。结果表明，在声能密度0.5~3 W/mL内，含固率1%~1.5%的剩余污泥经超声波作用后，上清液SCOD随作用时间呈线性升高；在声能密度1~3 W/mL内，含固率0.25%~0.5%的剩余污泥经超声波作用后，上清液SCOD随作用时间呈平缓缓慢升高。高声能密度超声波更适合对较高含固率污泥的细胞破碎；此情况下，上清液SCOD增幅、NH+4-N、TN及TP升幅均与声能密度正相关。经超声波作用6 min后，污泥形态结构已破坏。
- 超声波 /
- 剩余污泥 /
- 细胞破碎 /
- 声能密度 /
- 含固率
Abstract: High density ultrasonic was used to disintegrate waste activated sludge from SBR system in this study， which focused on the effect of solid content， ultrasonic density and time on sludge disintegration. The results showed that SCOD of supernatant presented a linear increase with ultrasonic time when ultrasonic density and solid content were in the range of 0.5~3 W/mL and 1%~1.5%， respectively. However， only slightly increase of SCOD with ultrasonic time was observed when ultrasonic density and solid content were in the range of 1~3 W/mL and 0.25%~0.5%， respectively. It could conclude that high density ultrasonic was more suitable for disintegratation of sludge with high solid content， in which the increase of SCOD， NH+4-N， TN and TP were all positively correlated with the ultrasonic density and structure of sludge could be destroyed after 6 min.
- ultrasonic /
- waste activated sludge /
- cell disruption /
- ultrasonic density /
- solid content

点击查看大图

计量

文章访问数: 1859
HTML全文浏览数: 994
PDF下载数: 833
施引文献: 0

沈会山, 胡勇有, 王广华, 梁树焜, 何向明, 谢义忠, 李凌云. 高声能密度超声波破碎污泥细胞效能的研究[J]. 环境工程学报, 2011, 5(9): 2115-2119.

引用本文:

沈会山, 胡勇有, 王广华, 梁树焜, 何向明, 谢义忠, 李凌云. 高声能密度超声波破碎污泥细胞效能的研究[J]. 环境工程学报, 2011, 5(9): 2115-2119.

Citation:

Shen Huishan, Hu Yongyou, Wang Guanghua, Liang Shukun, He Xiangming, Xie Yizhong, Li Lingyun. 5Disintegration of sludge cell by ultrasonic technique of high ultrasonic density[J]. Chinese Journal of Environmental Engineering, 2011, 5(9): 2115-2119.

高声能密度超声波破碎污泥细胞效能的研究

1. 华南理工大学环境科学与工程学院工业聚集区污染控制与生态修复教育部重点实验室，广州 510006；
2.华南理工大学制浆造纸工程国家重点实验室，广州 510640
3. 南海发展股份有限公司，南海 528200

收稿日期: 2010-04-26

基金项目:

广东省科技计划项目(2007A032302001)

关键词:

摘要: 采用超声波在较高声能密度下处理SBR的剩余污泥，主要考察了含固率、声能密度和作用时间对污泥细胞破碎效果的影响。结果表明，在声能密度0.5~3 W/mL内，含固率1%~1.5%的剩余污泥经超声波作用后，上清液SCOD随作用时间呈线性升高；在声能密度1~3 W/mL内，含固率0.25%~0.5%的剩余污泥经超声波作用后，上清液SCOD随作用时间呈平缓缓慢升高。高声能密度超声波更适合对较高含固率污泥的细胞破碎；此情况下，上清液SCOD增幅、NH+4-N、TN及TP升幅均与声能密度正相关。经超声波作用6 min后，污泥形态结构已破坏。

English Abstract

5Disintegration of sludge cell by ultrasonic technique of high ultrasonic density

1. Key Laboratory of Pollution Control and Ecological Remediation for Industial Agglomeration Area，Ministry of Education， College of Environmental Science and Engineering，South China University of Technology， Guangzhou 510006， China；2.State Key Lab oratory
3. Nanhai Development Company Limited， Nanhai 528200， Guangdong， China

Received Date: 2010-04-26

Fund Project:

Keywords:

Abstract: High density ultrasonic was used to disintegrate waste activated sludge from SBR system in this study， which focused on the effect of solid content， ultrasonic density and time on sludge disintegration. The results showed that SCOD of supernatant presented a linear increase with ultrasonic time when ultrasonic density and solid content were in the range of 0.5~3 W/mL and 1%~1.5%， respectively. However， only slightly increase of SCOD with ultrasonic time was observed when ultrasonic density and solid content were in the range of 1~3 W/mL and 0.25%~0.5%， respectively. It could conclude that high density ultrasonic was more suitable for disintegratation of sludge with high solid content， in which the increase of SCOD， NH+4-N， TN and TP were all positively correlated with the ultrasonic density and structure of sludge could be destroyed after 6 min.

全文HTML

参考文献 (0)

下载: 全尺寸图片幻灯片

返回文章

用微信扫码二维码

分享至好友和朋友圈

高声能密度超声波破碎污泥细胞效能的研究

5Disintegration of sludge cell by ultrasonic technique of high ultrasonic density

计量

出版历程

高声能密度超声波破碎污泥细胞效能的研究

English Abstract

5Disintegration of sludge cell by ultrasonic technique of high ultrasonic density

全文HTML

目录