添加晶种对沼气发酵液磷回收的影响研究

邹璇; 李亮; 王德汉; 邓加曦; 冯文谦; 李东; 孙永明

环境工程学报

添加晶种对沼气发酵液磷回收的影响研究

, , , , , ,

邹璇, 李亮, 王德汉, 邓加曦, 冯文谦, 李东, 孙永明. 添加晶种对沼气发酵液磷回收的影响研究[J]. 环境工程学报, 2012, 6(2): 489-495.

引用本文:

邹璇, 李亮, 王德汉, 邓加曦, 冯文谦, 李东, 孙永明. 添加晶种对沼气发酵液磷回收的影响研究[J]. 环境工程学报, 2012, 6(2): 489-495.

Zou Xuan, Li Liang, Wang Dehan, Deng Jiaxi, Feng Wenqian, Li Dong, Sun Yongming. Study on effect of crystalline seeds addition on phosphorus recovery from biogas fermentative liquid[J]. Chinese Journal of Environmental Engineering, 2012, 6(2): 489-495.

Citation:

Zou Xuan, Li Liang, Wang Dehan, Deng Jiaxi, Feng Wenqian, Li Dong, Sun Yongming. Study on effect of crystalline seeds addition on phosphorus recovery from biogas fermentative liquid[J]. Chinese Journal of Environmental Engineering, 2012, 6(2): 489-495.

添加晶种对沼气发酵液磷回收的影响研究

1.
华南农业大学资源环境学院环境工程系，广州 510642
2.
机科发展科技股份有限公司，北京 100044
3.
中国科学院广州能源研究所，广州 510640
基金项目:
科技部“十一五”国家科技支撑计划重大项目（2008BADC4B04）

广东省科技计划项目（2008b030302044）
中图分类号: X703

Study on effect of crystalline seeds addition on phosphorus recovery from biogas fermentative liquid

1.
Department of Environmental Science and Engineering， College of Resources and Environment， South China Agricultural University， Guangzhou 510642， China
2.
Machinery Technology Development Co.， Ltd.， Beijing 100044， China
3.
Guangzhou Institute of Energy Conversion， Chinese Academy of Sciences， Guangzhou 510640， China
Fund Project:

摘要: 以畜禽养殖废水经厌氧消化处理后的沼气发酵液为研究对象，采用曝气吹脱调节pH的处理方式。晶种采用海泡石粉、沸石粉和凹凸棒石粉3种天然矿物材料。考察了不同pH条件、晶种添加量和不同初始磷负荷对磷回收的影响，并利用扫描电镜能谱分析仪（SEM-EDX）对产物进行了表征分析。结果表明：3种晶种材料中，凹凸棒石粉对磷回收的促进效果最好。在pH从7.5到8.5之间海泡石粉、沸石粉和凹凸棒石粉均可将Rp(t)提高10%以上，8.5到9.5之间，添加海泡石粉和沸石粉对Rp(t)的提升幅度降低，添加凹凸棒石粉可以达到14%左右的提升幅度。海泡石粉和沸石粉添加量增大后Rp(t)有小幅的提升，但变化不规律，凹凸棒石粉的最佳添加量为0.92 g/L。初始PO3-4-P为90 mg/L时凹凸棒石粉对磷回收有最好的促进效果。添加凹凸棒石粉的产物在SEM图片上可看到明显有晶体覆盖，EDX图上出现了明显的强度较大的P组分峰，从微观的角度证实了添加凹凸棒石粉的促进作用。
- 磷回收 /
- 晶种 /
- 海泡石粉 /
- 沸石粉 /
- 凹凸棒石粉
Abstract: Taking the biogas fermentative liquid treated by anaerobic digestion process from livestock wastewater as the research object， using the treatment method of aeration stripping and using sepiolite powder， zeolite powder， attapulgite powder as crystalline seeds， the effects of different pH value， addition amount of crystalline seeds， initial phosphorus loads were investigated and characterization of crystalline product was analyzed using scanning electron microscopy (SEM) and energy dispersive X-ray analysis (EDX). The results are as follows: The effect of attapulgite powder for phosphorus recovery is the best among the three kinds of seeds in this study. Rp(t)increased more than 10% with the addition of the three crystalline seeds when pH value ranged between 7.5 to 8.5. When pH value ranged between 8.5 to 9.5， Rp(t) increased 14% after adding attapulgite powder while after adding sepiolite powder and zeolite powder Rp(t) reduced. So with the addition of attapulgite powder Rp(t) increased most and the optimal addition amount was 0.92 g/L. And Rp(t) was the highest when initial phosphate load was 90 mg/L when adding attapulgite powder. Crystal could be seen apparently from the SEM picture at the surface of crystalline product after addition of attapulgite powder， and a strong P peak was appeared on the EDX picture. The promotion of phosphorus recovery when adding attapulgite powder is conformed from microcosmic point of view.
- phosphorus recovery /
- seed /
- sepiolite powder /
- zeolite powder /
- attapulgite powder

点击查看大图

计量

文章访问数: 1912
HTML全文浏览数: 821
PDF下载数: 714
施引文献: 0

邹璇, 李亮, 王德汉, 邓加曦, 冯文谦, 李东, 孙永明. 添加晶种对沼气发酵液磷回收的影响研究[J]. 环境工程学报, 2012, 6(2): 489-495.

引用本文:

邹璇, 李亮, 王德汉, 邓加曦, 冯文谦, 李东, 孙永明. 添加晶种对沼气发酵液磷回收的影响研究[J]. 环境工程学报, 2012, 6(2): 489-495.

Citation:

Zou Xuan, Li Liang, Wang Dehan, Deng Jiaxi, Feng Wenqian, Li Dong, Sun Yongming. Study on effect of crystalline seeds addition on phosphorus recovery from biogas fermentative liquid[J]. Chinese Journal of Environmental Engineering, 2012, 6(2): 489-495.

添加晶种对沼气发酵液磷回收的影响研究

1. 华南农业大学资源环境学院环境工程系，广州 510642
2. 机科发展科技股份有限公司，北京 100044
3. 中国科学院广州能源研究所，广州 510640

收稿日期: 2010-11-24

基金项目:

科技部“十一五”国家科技支撑计划重大项目（2008BADC4B04）

广东省科技计划项目（2008b030302044）

关键词:

摘要: 以畜禽养殖废水经厌氧消化处理后的沼气发酵液为研究对象，采用曝气吹脱调节pH的处理方式。晶种采用海泡石粉、沸石粉和凹凸棒石粉3种天然矿物材料。考察了不同pH条件、晶种添加量和不同初始磷负荷对磷回收的影响，并利用扫描电镜能谱分析仪（SEM-EDX）对产物进行了表征分析。结果表明：3种晶种材料中，凹凸棒石粉对磷回收的促进效果最好。在pH从7.5到8.5之间海泡石粉、沸石粉和凹凸棒石粉均可将Rp(t)提高10%以上，8.5到9.5之间，添加海泡石粉和沸石粉对Rp(t)的提升幅度降低，添加凹凸棒石粉可以达到14%左右的提升幅度。海泡石粉和沸石粉添加量增大后Rp(t)有小幅的提升，但变化不规律，凹凸棒石粉的最佳添加量为0.92 g/L。初始PO3-4-P为90 mg/L时凹凸棒石粉对磷回收有最好的促进效果。添加凹凸棒石粉的产物在SEM图片上可看到明显有晶体覆盖，EDX图上出现了明显的强度较大的P组分峰，从微观的角度证实了添加凹凸棒石粉的促进作用。

English Abstract

Study on effect of crystalline seeds addition on phosphorus recovery from biogas fermentative liquid

1. Department of Environmental Science and Engineering， College of Resources and Environment， South China Agricultural University， Guangzhou 510642， China
2. Machinery Technology Development Co.， Ltd.， Beijing 100044， China
3. Guangzhou Institute of Energy Conversion， Chinese Academy of Sciences， Guangzhou 510640， China

Received Date: 2010-11-24

Fund Project:

Keywords:

Abstract: Taking the biogas fermentative liquid treated by anaerobic digestion process from livestock wastewater as the research object， using the treatment method of aeration stripping and using sepiolite powder， zeolite powder， attapulgite powder as crystalline seeds， the effects of different pH value， addition amount of crystalline seeds， initial phosphorus loads were investigated and characterization of crystalline product was analyzed using scanning electron microscopy (SEM) and energy dispersive X-ray analysis (EDX). The results are as follows: The effect of attapulgite powder for phosphorus recovery is the best among the three kinds of seeds in this study. Rp(t)increased more than 10% with the addition of the three crystalline seeds when pH value ranged between 7.5 to 8.5. When pH value ranged between 8.5 to 9.5， Rp(t) increased 14% after adding attapulgite powder while after adding sepiolite powder and zeolite powder Rp(t) reduced. So with the addition of attapulgite powder Rp(t) increased most and the optimal addition amount was 0.92 g/L. And Rp(t) was the highest when initial phosphate load was 90 mg/L when adding attapulgite powder. Crystal could be seen apparently from the SEM picture at the surface of crystalline product after addition of attapulgite powder， and a strong P peak was appeared on the EDX picture. The promotion of phosphorus recovery when adding attapulgite powder is conformed from microcosmic point of view.

全文HTML

参考文献 (0)

下载: 全尺寸图片幻灯片

返回文章

用微信扫码二维码

分享至好友和朋友圈

添加晶种对沼气发酵液磷回收的影响研究

Study on effect of crystalline seeds addition on phosphorus recovery from biogas fermentative liquid

计量

出版历程

添加晶种对沼气发酵液磷回收的影响研究

English Abstract

Study on effect of crystalline seeds addition on phosphorus recovery from biogas fermentative liquid

全文HTML

目录