高级搜索

铁盐和铝盐混凝对印染废水生化出水中溶解性有机污染物的去除特性

,  ,  ,  ,  , 

downloadPDF

上一篇

下一篇

李暮, 钱飞跃, 李欣珏, 李新, 孙贤波, 刘勇弟. 铁盐和铝盐混凝对印染废水生化出水中溶解性有机污染物的去除特性[J]. 环境工程学报, 2012, 6(11): 3833-3838.
引用本文: 李暮, 钱飞跃, 李欣珏, 李新, 孙贤波, 刘勇弟. 铁盐和铝盐混凝对印染废水生化出水中溶解性有机污染物的去除特性[J]. 环境工程学报, 2012, 6(11): 3833-3838.
shu
Li Mu, Qian Feiyue, Li Xinjue, Li Xin, Sun Xianbo, Liu Yongdi. Characteristic of different organic fractions removal from bio-treated effluents of textile and dyeing wastewater by ferric and aluminum coagulation[J]. Chinese Journal of Environmental Engineering, 2012, 6(11): 3833-3838.
Citation: Li Mu, Qian Feiyue, Li Xinjue, Li Xin, Sun Xianbo, Liu Yongdi. Characteristic of different organic fractions removal from bio-treated effluents of textile and dyeing wastewater by ferric and aluminum coagulation[J]. Chinese Journal of Environmental Engineering, 2012, 6(11): 3833-3838.
shu

铁盐和铝盐混凝对印染废水生化出水中溶解性有机污染物的去除特性

  • 1.

    华东理工大学资源与环境工程学院,上海 200237

  • 基金项目:

    国家"863"高技术研究发展计划重点项目(2009AA063904)

  • 中图分类号: X703

Characteristic of different organic fractions removal from bio-treated effluents of textile and dyeing wastewater by ferric and aluminum coagulation

  • 1.

    School of Resources and Environmental Engineering, East China University of Science and Technology, Shanghai 200237, China

  • Fund Project:

  • 摘要: 以三氯化铁和硫酸铝为混凝剂,印染废水二级生化出水为研究对象,并利用XAD-8/XAD-4 吸附树脂联用技术将印染废水生化出水中溶解性有机物分为疏水酸、非酸疏水物质、弱疏水物质及亲水物质4类有机物,通过小试实验探讨了2种混凝剂对生化出水中各类溶解性有机物的去除效果及特点。实验结果表明,对于该印染废水的生化出水,溶解性有机物的主要成分是疏水性物质,以DOC表征时占总DOC的75%,其中疏水酸约占41%,疏水性物质也是引起色度的主要物质,所占比例以ADMI7.6表征时为89%,其中以非酸疏水物质的贡献最大,达到52%,并且非酸疏水物质中不饱和双键或芳香环有机物的含量较高。在三氯化铁和硫酸铝各自最佳的混凝条件下,均能够有效去除由疏水性物质(疏水酸和非酸疏水物质)引起的色度,但三氯化铁对弱疏水性物质以及亲水物质的去除率高于硫酸铝,这使得三氯化铁对印染废水生化出水中的溶解性有机物的去除效果优于硫酸铝。并且三氯化铁和硫酸铝混凝工艺均能明显降低生化出水的毒性。
    Abstract: In this study, bio-treated effluents of textile and dyeing wastewater were treated by ferric chloride and aluminum sulfate coagulation process. Meanwhile, the dissolved organic matter from this bio-treated effluents was divided into four different fractions, hydrophobic acids, non-acid hydrophobics, transphilics and hydrophilics, by tandem XAD-8 and XAD-4 resins fractionation. Both characteristics and removal efficiency of different organic fractions were investigated through the pilot coagulation experiments. Results show that the hydrophobic organic fractions are the largest group in this bio-treated effluent, accounting for 75% in term of DOC, and hydrophobic acids account for 41%. Hydrophobics is also the dominating cause for the color of this effluent, accounting for 89% of the total ADMI7.6 value, and non-acid hydrophobics account for 52%. Non-acid hydrophobics have higher aromatic carbon contents than other organic fractions. Under the optimized condition of each coagulant, color caused by hydrophobics in this bio-treated effluent(both hydrophobic acids and non-acid hydrophobics fractions) can be removed significantly. But ferric salts have higher removal efficiency on transphilics and hydrophilics, which make ferric chloride have a better performance on the removal of dissolved organic matters from this bio-treated effluents than aluminum sulfate. The toxicity is obviously decreased through the coagulation process by each coagulant.
  • 加载中
  • [1] 毛艳梅, 奚旦立, 杨晓波. 印染废水深度处理技术及回用的现状和发展. 江苏纺织, 2005,(8): 46-48 Mao Y. M., Xi D. L., Yang X. B. Present situation and prospects of the advanced treatment and reuse of dyeing wastewater. Jiangsu Textile, 2005,(8): 46-48(in Chinese)
    [2] El-Gohary F., Tawfik A. Decolorization and COD reduction of disperse and reactive dyes wastewater using chemical coagulation followed by sequential batch reactor (Sbr) process. Desalination,2009,249(3): 1159-1164
    [3] Turhan K., Turgut Z. Decolorization of direct dye in textile wastewater by ozonization in a semi-batch bubble column reactor. Desalination, 2009, 242(1-3): 256-263
    [4] 戴日成, 张统, 郭茜,等. 印染废水水质特征及处理技术综述. 给水排水, 2000, 26(10): 33-37 Dai R. C., Zhang T., Guo Q., et al. Summary of printing-dyeing wastewater treatment technology. Water & Wastewater Engineering, 2000, 26(10): 33-37(in Chinese)
    [5] 张艳, 赵宜江,稽呜,等. 印染废水物理化学脱色方法的研究进展. 水处理技术, 2001,27(6): 311-313 Zhang Y., Zhao Y. J., Ji M., et al. Progress in the studies on the decolorization of printing and dyeing wastewater by physical and chemical technologies. Technology of Water Treatment, 2001, 27(6): 311-313(in Chinese)
    [6] 黄碧娟, 黄瑞敏, 郭嘉,等. 印染废水的混凝脱色研究. 环境科学与技术, 2009, 32(10): 166-168 Huang B. J., Huang R. M., Guo J., et al. Decolorization of dyeing wastewater by coagulation. Environmental Science & Technology, 2009, 32(10): 166-168(in Chinese)
    [7] Kao C., Chou M., Fang W., et al. Regulating colored textile wastewater by 3/31 wavelength admi methods in taiwan. Chemosphere, 2001, 44(5): 1055-1063
    [8] 王丽莎, 魏东斌, 胡洪营. 发光细菌毒性测试条件的优化与毒性参照物的应用. 环境科学研究, 2004, 17(4): 61-62 Wang L. S.,Wei D. B., Hu Hongying. Optimization of luminescent bacteria toxicity test and application of toxicity reference substance. Research of Environmental Sciences, 2004, 17(4): 61-62(in Chinese)
    [9] 龚剑丽, 刘勇弟, 孙贤波,等. 城市污水二级生化出水中有机污染物特性表征. 环境化学, 2007, 26(5): 706-707 Gong J. L., Sun X. B., Liu Y. D., et al. Characteristics of organic fractions in secondary effluent of municipal wastewater. Environmental Chemistry, 2007, 26(5): 706-707(in Chinese)
    [10] 龚剑丽, 孙贤波, 刘勇弟,等. 焦化废水二级生化出水中有机污染物的氧化特性. 环境化学, 2008, 27(2): 193-196 Gong J. L., Sun X. B., Liu Y. D. et al. Oxidative characteristics of organic fractions in secondary effluent of coking wastewater. Environmental Chemistry, 2008, 27(2): 193-196(in Chinese)
    [11] Weishaar J. L., Aiken G. R., Bergamaschi B. A., et al. Evaluation of specific ultraviolet absorbance as an indicator of the chemical composition and reactivity of dissolved organic carbon. Environmental Science & Technology, 2003, 37(20): 4702-4708
    [12] Gong J., Liu Y., Sun X. O3 and UV/O3 oxidation of organic constituents of biotreated municipal wastewater. Water Research, 2008, 42(4-5): 1238-1244
    [13] 董秉直, 曹达文, 范瑾初. 强化混凝中不同分子质量有机物的变化特点. 工业水处理, 2003, 23(9): 41-43 Dong B. Z., Cao D. W., Fan J. C. Characteristics of the changes in every molecular weight distribution of organics by enhanced coagulation. Industrial Water Treatment, 2003, 23(9): 41-43(in Chinese)
    [14] Matilainen A., Lindqvist N., Tuhkanen T. Comparison of the effiency of aluminium and ferric sulphate in the removal of natural organic matter during drinking water treatment process. Environmental Technology, 2005, 26(8): 867-876
    [15] 周玲玲, 张永吉, 孙丽华, 等. 铁盐和铝盐混凝对水中天然有机物的去除特性研究. 环境科学, 2008,29(5): 1187-1191 Zhou L. L., Zhang Y. J., Sun L. H., et al. Characteristic of natural organic matter removal by Ferric and Aluminum coagulation. Environmental Science, 2008, 29(5): 1187-1191(in Chinese)
    [16] 许雯佳, 孙贤波, 张蕾, 等. 黄浦江原水中各类有机物在铝盐混凝过程中的去除效果. 环境化学, 2009,28(6): 804-808 Xu W. J., Sun X. B., Zhang L., et al. Study on removal effect of different organic fractions from micro-polluted raw water by coagulation. Environmental Chemistry, 2009,28(6): 804-808(in Chinese)
  • 加载中
WeChat 点击查看大图
计量
  • 文章访问数:  2445
  • HTML全文浏览数:  1110
  • PDF下载数:  2283
  • 施引文献:  0
出版历程
  • 收稿日期:  2011-07-05
  • 刊出日期:  2012-11-09
李暮, 钱飞跃, 李欣珏, 李新, 孙贤波, 刘勇弟. 铁盐和铝盐混凝对印染废水生化出水中溶解性有机污染物的去除特性[J]. 环境工程学报, 2012, 6(11): 3833-3838.
引用本文: 李暮, 钱飞跃, 李欣珏, 李新, 孙贤波, 刘勇弟. 铁盐和铝盐混凝对印染废水生化出水中溶解性有机污染物的去除特性[J]. 环境工程学报, 2012, 6(11): 3833-3838.
shu
Li Mu, Qian Feiyue, Li Xinjue, Li Xin, Sun Xianbo, Liu Yongdi. Characteristic of different organic fractions removal from bio-treated effluents of textile and dyeing wastewater by ferric and aluminum coagulation[J]. Chinese Journal of Environmental Engineering, 2012, 6(11): 3833-3838.
Citation: Li Mu, Qian Feiyue, Li Xinjue, Li Xin, Sun Xianbo, Liu Yongdi. Characteristic of different organic fractions removal from bio-treated effluents of textile and dyeing wastewater by ferric and aluminum coagulation[J]. Chinese Journal of Environmental Engineering, 2012, 6(11): 3833-3838.
shu

铁盐和铝盐混凝对印染废水生化出水中溶解性有机污染物的去除特性

  • 1. 华东理工大学资源与环境工程学院,上海 200237
  • 收稿日期:  2011-07-05
基金项目:

国家"863"高技术研究发展计划重点项目(2009AA063904)

摘要: 以三氯化铁和硫酸铝为混凝剂,印染废水二级生化出水为研究对象,并利用XAD-8/XAD-4 吸附树脂联用技术将印染废水生化出水中溶解性有机物分为疏水酸、非酸疏水物质、弱疏水物质及亲水物质4类有机物,通过小试实验探讨了2种混凝剂对生化出水中各类溶解性有机物的去除效果及特点。实验结果表明,对于该印染废水的生化出水,溶解性有机物的主要成分是疏水性物质,以DOC表征时占总DOC的75%,其中疏水酸约占41%,疏水性物质也是引起色度的主要物质,所占比例以ADMI7.6表征时为89%,其中以非酸疏水物质的贡献最大,达到52%,并且非酸疏水物质中不饱和双键或芳香环有机物的含量较高。在三氯化铁和硫酸铝各自最佳的混凝条件下,均能够有效去除由疏水性物质(疏水酸和非酸疏水物质)引起的色度,但三氯化铁对弱疏水性物质以及亲水物质的去除率高于硫酸铝,这使得三氯化铁对印染废水生化出水中的溶解性有机物的去除效果优于硫酸铝。并且三氯化铁和硫酸铝混凝工艺均能明显降低生化出水的毒性。

English Abstract

    全文HTML

参考文献 (16)

返回顶部

目录

/

返回文章
返回

Copyright © 2019 中国科学院生态环境研究中心