高级搜索

六铝酸盐催化剂的催化还原脱硫脱硝性能

,  , 

downloadPDF

上一篇

下一篇

任晓光, 朱旭东, 李富霞. 六铝酸盐催化剂的催化还原脱硫脱硝性能[J]. 环境工程学报, 2013, 7(2): 668-672.
引用本文: 任晓光, 朱旭东, 李富霞. 六铝酸盐催化剂的催化还原脱硫脱硝性能[J]. 环境工程学报, 2013, 7(2): 668-672.
shu
Ren Xiaoguang, Zhu Xudong, Li Fuxia. Properties of hexaaluminate catalysts and catalytic reduction activity for desulfurization and denitrification[J]. Chinese Journal of Environmental Engineering, 2013, 7(2): 668-672.
Citation: Ren Xiaoguang, Zhu Xudong, Li Fuxia. Properties of hexaaluminate catalysts and catalytic reduction activity for desulfurization and denitrification[J]. Chinese Journal of Environmental Engineering, 2013, 7(2): 668-672.
shu

六铝酸盐催化剂的催化还原脱硫脱硝性能

  • 1.

    北京石油化工学院化学工程学院,北京 102617

  • 2.

    北京化工大学化学工程学院,北京 100029

  • 基金项目:

    国家自然科学基金资助项目(21076025)

  • 中图分类号: X511

Properties of hexaaluminate catalysts and catalytic reduction activity for desulfurization and denitrification

  • 1.

    College of Chemical Engineering, Beijing Institute of Petro-Chemical Technology, Beijing 102617, China

  • 2.

    College of Chemical Engineering, Beijing University of Chemical Technology, Beijing 100029, China

  • Fund Project:

  • 摘要: 采用共沉淀法制备Cu和Fe掺杂的六铝酸盐催化剂(SrCuxFe1-xAl11O19-δ,x为0,0.2,0.4,0.5,0.6,0.8,1),通过XRD、TPR、BET等技术方法对催化剂的结构及性质进行了研究,并考察了以CO为还原剂的催化脱硝活性。结果表明,用碳酸铵作为沉淀剂在1 200℃焙烧4 h可以形成完整的六铝酸盐晶型,Cu和Fe能够取代Al3+,很好地促进六铝酸盐晶体结构的形成;SrCuxFe1-xAl11O19-δ催化剂有很好的脱硫脱硝催化活性,此类型的催化剂均使SO2、NO的转化率在空速为6 000 h-1下达到了80%和90%以上。向体系中加入氧气会对催化活性有较大影响。
    Abstract: Cu, Fe substituted hexaaluminates catalysts (SrCuxFe1-xAl11O19-δ, x=0,0.2,0.4,0.5,0.6,0.8,1) were prepared with co-precipitation method. The structure and physico-chemical properties of the samples were characterized by means of XRD, TPR and BET techniques. CO as reducer, the activity of desulfurization and denitrification over the prepared samples were measured in a miniature fixed bed reactor. The results showed that the catalysts prepared using (NH4)2CO3 as precipitant could obtain good hexaaluminate phase under 1 200℃ calcinations for 4 h. Cu,Fe could be contributed to form the hexaaluminate lattice because of their good synergistic reaction. SrCux Fe1-xAl11O19-δ possessed highest catalytic activity in all the samples for desulfurization and denitrification reaction. The SO2 and NO convertion rate could reach to more than 80% and 90% under condition 6 000 h-1 airspeed. It would have a great effect under the condition of O2 existed in the catalytic reduction system.
  • 加载中
  • [1] 黄振中.中国大气污染防治技术综述.世界科技研究与发展,2004,26(2):30-34 Huang Zhenzhong.Air pollution prevention and control technologies in China. World Sci-Tech R & D, 2004,26(2):30-34(in Chinese)
    [2] 贾毅峰,兰雯.浅谈氮氧化物的污染与治理技术.广西轻工业,2007,(9):98-99 Jia Yifeng,Lan Wen.A brief introduction on pollution treatment technology of nitrogen oxides.Guangxi Journal of Light Industry, 2007,(9):98-99(in Chinese)
    [3] 汪小蕾,朴桂林,谢浩,等.活性炭选择性催化还原NOx.东南大学学报(自然科学版),2011,41(1):145-149 Wang Xiaolei,Piao Guilin,Xie Hao,et al.Selective catalytic reduction of NOx by activated carbon. Journal of Southeast University(Natural Science Edition), 2011,41(1):145-149(in Chinese)
    [4] 任雯,赵博,禚玉群,等.NaY分子筛担载FeSO4催化剂用于氨气还原NOx的性能.化工学报,2011,62(2):362-368 Ren Wen,Zhao Bo,Zhuo Yuqun,et al. Capability of molecular sieve-supported FeSO4 catalyst for selective catalytic reduction of NOx. CIESC Journal, 2011,62(2):362-368(in Chinese)
    [5] 徐青,郑章靖,凌长明,等.低温选择性催化还原脱除NOx的催化剂的研究进展.环境污染与防治,2011,33(6):81-85 Xu Qing,Zheng Zhangjing,Ling Changming,et al.Research progress of catalyst for selective catalytic reduction of NOx at low temperature. Environmental Pollution & Control, 2011,33(6):81-85(in Chinese)
    [6] 楼莉萍.负载型TiO2及CexTi(1-x)O2催化剂对NO+CO反应的催化作用.杭州:浙江大学博士学位论文,2003 Lou Liping.Catalytic properties of TiO2 based and CexTi1-xO2 based catalysts in NO+CO reaction.Hangzhou:Doctoral Dissertatim of Zhejiang University,2003(in Chinese)
    [7] 王勇. NiO/CeO2催化剂上CO还原NO的反应研究.大连:大连理工大学博士学位论文,2007 Wang Yong.The study on catalytic reduction of NO by CO over NiO/CeO2 catalyst.Dalian: Doctoral Dissertation of Dalian University of Technology,2007(in Chinese)
    [8] Masato Machida,Koichi Eguchi,Hiromichi Arai.Effect of structural modification on the catalytic property of Mn-substituted hexaaluminates.Journal of Catalysis,1990,123(2):477-485
    [9] 郑建东.搀杂六铝酸盐高温燃烧催化剂的制备及其在甲烷催化燃烧中性能的研究.北京:北京化工大学博士学位论文,2008 Zheng Jiandong.Study on catalysts on used for simultaneous removal of SOx , NOx from fuel gas.Beijing: Doctoral Dissertation of Beijing University of Chemical and Technology,2008(in Chinese)
    [10] 宋永吉,董留涛,李翠清,等.不同方法制备LaCu(0.8)Zn(0.2)Al(11)O(19-δ)催化剂及其催化分解N2O活性研究.环境污染与防治,2009,31(9):19-22 Song Yongji,Dong Liutao,Li Cuiqing,et al. Preparation of N2O decomposition catalyst LaCu0.8Zn0.2Al11O19-δ. Environmental Pollution & Control, 2009,31(9):19-22(in Chinese)
    [11] Marina V. Bukhtiyarova,Aleksandra S. Ivanova,Lyudmila M.Plyasova,et al. Selective catalytic reduction of nitrogen oxide by ammonia on Mn(Fe)-substituted Sr(La) aluminates. Journal of Molecular Catalysis A:Chemical,2009,357(2):193-205
    [12] 楼莉萍,蒋晓原,陈英旭,等.CuO/TiO2的制备及对NO+CO反应性能的研究.燃料化学学报,2003,31(5):490-495 Lou Liping,Jiang Xiaoyuan,Chen Yingxu,et al.Studies on preparation of CuO/TiO2 and catalytic activities for NO+CO reaction. Journal of Fuel Chemistry and Technology,2003,31(5):490-495(in Chinese)
    [13] Liang Meisheng,Kang Wenkai,Xie Kechang.Comparison of reduction behavior of Fe2O3,ZnO and ZnFe2O4 by TPR technique. Journal of Natural Gas Chemistry,2009,18(1):110-113
    [14] 任晓光,任超,李晓燕.过渡金属离子复合掺杂的六铝酸盐催化剂的脱硝性能.环境污染与防治,2011,33(9):4-7 Ren Xiaoguang,Ren Chao,Li Xiaoyan. Denitrification properties of hexaaluminates co-doped with different transition metals. Environmental Pollution & Control, 2011,33(9):4-7(in Chinese)
  • 加载中
WeChat 点击查看大图
计量
  • 文章访问数:  2206
  • HTML全文浏览数:  1029
  • PDF下载数:  1526
  • 施引文献:  0
出版历程
  • 收稿日期:  2012-07-04
  • 刊出日期:  2013-02-02

六铝酸盐催化剂的催化还原脱硫脱硝性能

  • 1. 北京石油化工学院化学工程学院,北京 102617
  • 2. 北京化工大学化学工程学院,北京 100029
  • 收稿日期:  2012-07-04
基金项目:

国家自然科学基金资助项目(21076025)

摘要: 采用共沉淀法制备Cu和Fe掺杂的六铝酸盐催化剂(SrCuxFe1-xAl11O19-δ,x为0,0.2,0.4,0.5,0.6,0.8,1),通过XRD、TPR、BET等技术方法对催化剂的结构及性质进行了研究,并考察了以CO为还原剂的催化脱硝活性。结果表明,用碳酸铵作为沉淀剂在1 200℃焙烧4 h可以形成完整的六铝酸盐晶型,Cu和Fe能够取代Al3+,很好地促进六铝酸盐晶体结构的形成;SrCuxFe1-xAl11O19-δ催化剂有很好的脱硫脱硝催化活性,此类型的催化剂均使SO2、NO的转化率在空速为6 000 h-1下达到了80%和90%以上。向体系中加入氧气会对催化活性有较大影响。

English Abstract

    全文HTML

参考文献 (14)

目录

/

返回文章
返回

Copyright © 2019 中国科学院生态环境研究中心