高级搜索

MFC-MBR耦合系统运行效果

,  ,  , 

downloadPDF

上一篇

下一篇

王翠娜, 田禹, 苏欣颖, 李慧. MFC-MBR耦合系统运行效果[J]. 环境工程学报, 2013, 7(8): 2855-2860.
引用本文: 王翠娜, 田禹, 苏欣颖, 李慧. MFC-MBR耦合系统运行效果[J]. 环境工程学报, 2013, 7(8): 2855-2860.
shu
Wang Cuina, Tian Yu, Su Xinying, Li Hui. Analysis of performances of microbial fuel cell-membrane bioreactor system[J]. Chinese Journal of Environmental Engineering, 2013, 7(8): 2855-2860.
Citation: Wang Cuina, Tian Yu, Su Xinying, Li Hui. Analysis of performances of microbial fuel cell-membrane bioreactor system[J]. Chinese Journal of Environmental Engineering, 2013, 7(8): 2855-2860.
shu

MFC-MBR耦合系统运行效果

  • 1.

    哈尔滨工业大学市政环境工程学院, 哈尔滨 150090

  • 2.

    哈尔滨工业大学城市水资源与水环境国家重点实验室, 哈尔滨 150090

  • 基金项目:

    国家水体污染控制与治理科技重大专项(2013ZX07201007)

    城市水资源与水环境国家重点实验室(2011DX01)

    高等学校博士学科点专项科研基金(20112302110060)

    国家创新研究群体科学基金(51121062)

  • 中图分类号: X703.1

Analysis of performances of microbial fuel cell-membrane bioreactor system

  • 1.

    School of Municipal and Environmental Engineering, Harbin Institute of Technology, Harbin 150090, China

  • 2.

    State Key Laboratory of Urban Water Resource and Environment, Harbin Institute of Technology, Harbin 150090, China

  • Fund Project:

  • 摘要: 膜生物反应器(MBR)是一种高效的污水处理工艺,而微生物燃料电池(MFC)能有效降解污泥中的胞外生物有机质(EBOM)并回收电能。将MFC与MBR联用,建立了一套能够有效抑制膜污染同时回收电能的新系统——MFC-MBR耦合系统,MBR的剩余污泥经MFC处理后回流。以传统MBR为对照,对耦合系统中污水处理效果、膜污染情况和污泥混合液的性质进行研究。研究表明,耦合系统的污水处理效果没有明显恶化,COD去除率为94%,NH4+-N的去除率为92%。耦合系统能够有效减缓膜污染的发生,清洗周期延长了28%。污泥混合液的MLVSS/MLSS稳定在80%~88%,系统内几乎没有无机颗粒积累。松散结合态胞外聚合物(LB-EPS)降低了48%,使污泥混合液性质得到改善。较低的污泥比阻(2.69×1012m/kg)和标准化毛细吸水时间(1.67s·L/gMLSS),证明耦合系统污泥混合液脱水性能提高了。
    Abstract: Membrane bioreactor (MBR) is an effective process for wastewater treatment, whereas the process of microbial fuel cell (MFC) can effectively degrade extracellular biological organic matter (EBOM) and recover electricity. A new process for combining MBR with MFCs was established to mitigate membrane fouling and recover electricity. The excess sludge of MBR was treated by MFCs, and then recycled to MBR. The combined system was compared with the conventional MBR with respect to the performances of wastewater treatment, the membrane fouling and the characteristics of mixed liquor. The result showed that the effluent quality of the combined system was not deteriorated significantly, with removal efficiencies of 94% and 92% for COD and NH4+-N, respectively. Membrane fouling of the combined system was mitigated dramatically and the chemical cleaning cycle was prolonged by 28%. The ratios of mixed liquor volatile suspended solids (MLVSS) to mixed liquor suspended solids (MLSS) for the two systems were almost identical, in the range 80%~88%, indicating that the inorganics from the MFCs did not accumulate as particulates in the MBR. Loosely bound extracellular polymeric substances (LB-EPS) decreased by 48%, resulting that the sludge was modified. Lower specific resistance to filtration (2.69×1012 m/kg) and normalized capillary suction time (1.67 s·L/g MLSS) demonstrated that the dewaterability of mixed liquor in the combined system was improved.
  • 加载中
  • [1] Judd S. The MBR Book: Principles and Applications of Membrane Bioreactors in Water and Wastewater Treatment. Elsevier, Oxford, 2006
    [2] Yang W., Cicek N., Ilg J. State-of-the-art of membrane bioreactors: Worldwide research and commercial applications in North America. Membr. Sci., 2006,207(1-2):201-211
    [3] Chang I. S., Clech P. L., Jefferson B., et al. Membrane fouling in membrane bioreators for wastewater treatment. Journal of Environmental Engineering, 2002,128(11):1018-1029
    [4] 吴金玲,黄霞. 膜生物反应器混合液性质对膜污染影响的研究进展. 环境污染治理技术与设备, 2006,7(2):16-24 Wu Jinling, Huang Xia. Research progress on effect of mixed liquor characteristics on membrane fouling in membrane reactors. Techniques and Equipment for Environmental Pollution Control, 2006,7(2):16-24(in Chinese)
    [5] 康晓菲. 与蠕虫床联用的污水处理工艺的选择和运行效果研究. 哈尔滨:哈尔滨工业大学硕士学位论文, 2011 Kang Xiaofei. Selection the sewage treatment combined sessile worm reactor and the performance of the combined process. Harbin: Master's Degree Thesis of Harbin Institute of Technology, 2011(in Chinese)
    [6] Hwang Byung-Kook, Kim Jae-Hyuk, Ahn Chang Hoon, et al. Effect of disintegrated sludge recycling on membrane permeability in a membrane bioreactor combined with a turbulent jet flow ozone contactor. Water Res., 2010,44(6):1833-1840
    [7] Davis J. B., Yarbrough H. F. Preliminary experiments on a microbial fuel cell. Science, 1962,137(3530):615-616
    [8] Liu Z., Li X., Jia B., et al. Production of electricity from surplus sludge using a single chamber floating-cathode microbial fuel cell. Water Sci. Technol., 2009,60(9):2399-2404
    [9] Fr∅lund B., Palmgren R., Keiding K., et al. Extraction of extracellular polymers from activated sludge using a cation exchange resin. Water Res., 1996,30(8):1749-1758
    [10] Jiang J.Q., Zhao Q.L., Wei L.L., et al. Extracellular biological organic matters in microbial fuel cell using sewage sludge as fuel. Water Res., 2010,44(7):2163-2170
    [11] Fytili D., Zabaniotou. A utilization of sewage sludge in EU application of old and new methods: A review. Renewable and Sustainable Energy Reviews, 2008,12(1):116-140
    [12] 国家环境保护总局. 水和废水监测分析方法(第4版). 北京:中国环境科学出版社,2002
    [13] Li X. Y., Yang S. F. Influence of loosely bound extracellular polymeric substances (EPS) on the flocculation, sedimentation and dewaterability of activated sludge. Water Res., 2007,41(5):1022-1030
    [14] Apha, Awwa, Wef. Standard Methods for the Examination of Water and Wastewater(21st ed). APHA, Washington DC, USA, 2005
    [15] Mikkelsen L. H., Keiding K. Physico-chemical characteristics of full scale sewage sludges with implications to dewatering. Water Res., 2002,36(10):2451-2462
    [16] Sakai Y., Fukase T., Yasui H., et al. An activated sludge process without excess sludge production. Water Sci. Technol., 1997,36(11)攺?戶椳漭爱攷愰挼瑢潲爾獛???洠灏慧据瑩?潲映?洮攬愠湗?捳敮汩汥?牳敫獩椠摃攮測挠敇?瑡楳浭敩?慫渠摁?琠桍敥?换潲湡瑮牥椠扢畩瑯楲湥条?晴慯捲琠潦牯獵???湧瘠楩牮漠湳??匭捣楲??呩散捡桬渠潦汩????ぴど???っ??????は??水????扯牣?孬㈠?嵲?却桩慣潡??楦浬極湸朠??坮慣湥杰??甠慍湥穭桢慲漮??塣畩??甠愲挰栰攴測朲??攨琱?愲氩???昱昭攱挷琷猼?潲显?由永瑝爠慙獡潳湵楩挠?瀮爬攠瑎牡敫慡瑭浵敲湡琠?漮測?獓污畫摵杭敡?摓攮眬愠瑥整爠慡扬椮氠楁琠祦?慬湬搭?散硡瑬牥愠捯数汥汲畡汴慩牯?瀠潯汦礠浡攠牮楯捶?獬甠扡獣瑴慩湶捡整獥?搠楳獬瑵牤楧扥甠瑰楲潯湣?楳湳?海敩獴潨灯桵楴氠楥捸?慥湳慳攠牳潬扵楤捧?搠楰杲敯獤瑵楣潴湩???漠畗牡湴慥汲?潓晣??渠癔楥牣潨湮浯敬渮琬愠氱?匹挶椬攳渴挨攳猭??呼????名日??????????す?扮牧?孓金?嵆??漠牌獩琠敘爮???????呬桵敥?牣桥敳漠汯潦朠楥捸慴汲?慣湥摬?灵桬祡獲椠捰潯?捹桭敥浲楩捣愠汳?换桳慴牡慮捣瑥敳爠椨獅瑐楓挩猠?潮映?獨敥眠慣杨敡?獡汣畴摥杲敩獳???湳稠祯浦攠??楴捩牶潡扴??吠敳捬桵湤潧汥????づひ㈠??の??????べ????te conditions. Process Biochemistry, 2009,44(1):91-96
    [17] Laspidou C. S., Rittmann B. E. A unified theory for extracellular polymeric substances, soluble microbial products, and active and inert biomass. Water Res., 2002,36(11):2711-2720
    [18] Rosenberger S., Evenblij H., Poele S., et al. The importance of liquid phase analyses to understand fouling in membrane assisted activated sludge processes-six case studies of different European research groups. Membr. Sci., 2005,263(1-2):113-126
    [19] Wang Zhiwei, Wu Zhichao, Tang Shujuan. Extracellular polymeric substances (EPS) properties and their effects on membrane fouling in a submerged membrane bioreactor. Water Res., 2009,43(9):2504-2512
    [20] Meng Fangang, Zhang Hanmin, Yang Fenglin, et al. Identification of activated sludge properties affecting membrane fouling in submerged membrane bioreactors. Separation and Purification Technology, 2006,51(1):95-103
    [21] Bai R., Leow H.F. Microfiltration of activated sludge wastewater-the effect of system operation parameters. Separation and Purification Technology, 2002,29(2):189-198
    [22] Bizi M. Filtration characteristics of a mineral mud with regard to turbulent shearing. Membr. Sci., 2008,320(1-2):533-540
    [23] Elisabeth Neyens, Jan Baeyens, Raf Dewil, et al. Advanced sludge treatment affects extracellular polymeric substances to improve activated sludge dewatering. Journal of Hazardous Materials, 2004,106(2-3):83-92
    [24] How Y. N. G., Teck Wee Tan, Say Leong Ong. Membrane rouling of submerged membran
  • 加载中
WeChat 点击查看大图
计量
  • 文章访问数:  2042
  • HTML全文浏览数:  894
  • PDF下载数:  1687
  • 施引文献:  0
出版历程
  • 收稿日期:  2012-05-13
  • 刊出日期:  2013-08-12
王翠娜, 田禹, 苏欣颖, 李慧. MFC-MBR耦合系统运行效果[J]. 环境工程学报, 2013, 7(8): 2855-2860.
引用本文: 王翠娜, 田禹, 苏欣颖, 李慧. MFC-MBR耦合系统运行效果[J]. 环境工程学报, 2013, 7(8): 2855-2860.
shu
Wang Cuina, Tian Yu, Su Xinying, Li Hui. Analysis of performances of microbial fuel cell-membrane bioreactor system[J]. Chinese Journal of Environmental Engineering, 2013, 7(8): 2855-2860.
Citation: Wang Cuina, Tian Yu, Su Xinying, Li Hui. Analysis of performances of microbial fuel cell-membrane bioreactor system[J]. Chinese Journal of Environmental Engineering, 2013, 7(8): 2855-2860.
shu

MFC-MBR耦合系统运行效果

  • 1.  哈尔滨工业大学市政环境工程学院, 哈尔滨 150090
  • 2.  哈尔滨工业大学城市水资源与水环境国家重点实验室, 哈尔滨 150090
  • 收稿日期:  2012-05-13
基金项目:

国家水体污染控制与治理科技重大专项(2013ZX07201007)

城市水资源与水环境国家重点实验室(2011DX01)

高等学校博士学科点专项科研基金(20112302110060)

国家创新研究群体科学基金(51121062)

摘要: 膜生物反应器(MBR)是一种高效的污水处理工艺,而微生物燃料电池(MFC)能有效降解污泥中的胞外生物有机质(EBOM)并回收电能。将MFC与MBR联用,建立了一套能够有效抑制膜污染同时回收电能的新系统——MFC-MBR耦合系统,MBR的剩余污泥经MFC处理后回流。以传统MBR为对照,对耦合系统中污水处理效果、膜污染情况和污泥混合液的性质进行研究。研究表明,耦合系统的污水处理效果没有明显恶化,COD去除率为94%,NH4+-N的去除率为92%。耦合系统能够有效减缓膜污染的发生,清洗周期延长了28%。污泥混合液的MLVSS/MLSS稳定在80%~88%,系统内几乎没有无机颗粒积累。松散结合态胞外聚合物(LB-EPS)降低了48%,使污泥混合液性质得到改善。较低的污泥比阻(2.69×1012m/kg)和标准化毛细吸水时间(1.67s·L/gMLSS),证明耦合系统污泥混合液脱水性能提高了。

English Abstract

    全文HTML

参考文献 (24)

返回顶部

目录

/

返回文章
返回

Copyright © 2019 中国科学院生态环境研究中心