高级搜索

城市污泥桨叶式干化优化实验研究

,  , 

downloadPDF

上一篇

下一篇

申维真, 张宏伟, 张羽. 城市污泥桨叶式干化优化实验研究[J]. 环境工程学报, 2013, 7(11): 4575-4580.
引用本文: 申维真, 张宏伟, 张羽. 城市污泥桨叶式干化优化实验研究[J]. 环境工程学报, 2013, 7(11): 4575-4580.
shu
Shen Weizhen, Zhang Hongwei, Zhang Yu. Experiments on optimization of sewage sludge drying by paddle dryer[J]. Chinese Journal of Environmental Engineering, 2013, 7(11): 4575-4580.
Citation: Shen Weizhen, Zhang Hongwei, Zhang Yu. Experiments on optimization of sewage sludge drying by paddle dryer[J]. Chinese Journal of Environmental Engineering, 2013, 7(11): 4575-4580.
shu

城市污泥桨叶式干化优化实验研究

  • 1.

    北京机电院高技术股份有限公司, 北京 100027

  • 基金项目:

    北京机电院高技术股份有限公司课题(K1083)

  • 中图分类号: X705

Experiments on optimization of sewage sludge drying by paddle dryer

  • 1.

    Beijing Machinery and Electricity Institute, Hi-Tech Co. Ltd., Beijing 100027, China

  • Fund Project:

  • 摘要: 桨叶式干化是一种高效的污泥干化处理技术,为了降低污泥含水率达到污泥减量减容效果,同时为后期的工程化应用提供依据和参考,实验采用倾斜盘式桨叶干燥机,以北京市污水处理厂污泥为研究对象,研究了不同滞留时间、污泥供给量、干燥机换热面积等因素对桨叶式干化处理后蒸发速度和污泥含水率的影响,并从处理效率以及与工程化应用数据对比分析等多方面考核,确定最佳工艺运行条件:使用0.5~0.8 MPa的蒸气,蒸发速率达到14~21.8 kg/(m2·h)时,干化处理后污泥含水率<40%。
    Abstract: Paddle drying is a high efficient sludge drying process. In order to reduce sludge capacity by decreasing the sludge moisture content and provide the basis and reference for later engineering application and further upgrading reconstruction projects, some experiments were done using paddle dryer. Taking the Beijing sewage sludge as sample through paddle drying process, the effects of retention time, height of outlet damper, sludge allowance, and heat exchange area of the dryer on evaporation rate, the moisture content of sludge, and the processing efficiency were researched. Besides those, different factors including treatment efficiency, the data analysis of engineering application were investigated. The optimal operating conditions and parameters were steam pressure of 0.5~0.8 MPa, evaporation rate of 14~21.8 kg/(m2·h). The moisture content of sewage sludge after drying was below 40%.
  • 加载中
  • [1] 丘锦荣,吴启堂,卫泽斌,等.城市污泥干燥研究进展.生态环境,2007,16(2):667-671 Qiu J.R., Wu Q.T., Wei Z.B., et al.Research advances in municipal sludge drying. Ecological Environment,2007,16(2):667-671(in Chinese)
    [2] Wei Y.S.,Fan Y.B.,Wang M.J. A cost analysis of sewage sludge composting for small and mid-scale municipal wastewater treatment plants.Resources, Conservation and Recycling,2001,33(3):203-216
    [3] Strauss M., Larmie S.A., Heinss U. Treatment of sludges from on-site sanitation——Low-cost options. Water Science and Technology, 1997, 35(6):129-136
    [4] Tae I.O., Jong S.C., Jeong E.K., et al. A study on the dewatering of industrial waste sludge by fry-drying technology.Journal of Hazardous Materials, 2009, 168(1): 445-450
    [5] Stefanakisa A.I., Akratosa C.S., Melidisb P.,et al. Surplus activated sludge dewatering in pilot-scale sludge drying reed beds.Journal of Hazardous Materials, 2009, 172(2-3):1122-1130
    [6] Alexandros I. S., Vassilios A. Tsihrintzis.Effect of various design and operation parameters on performance of pilot-scale sludge drying reed beds.Ecological Engineering, 2012,38(1):65-78
    [7] Peregrinaa C., Rudolphb V., Lecomtea D. Immersion frying for the thermal drying of sewage sludge: An economic assessment.Journal of Environmental Management, 2008, 86(1): 246-261
    [8] 马侠,蒋旭光,马增益,等. 桨叶式干燥机污泥干燥试验研究.能源工程,2006,1(3):56-60 Ma X.,Jiang X.G.,Ma Z.Y.,et al. Experimental study on drying sewage sludge with paddle dryer. Energy Engineering,2006,1(3):56-60(in Chinese)
    [9] 韦朝海,陈传好.污泥处理、处置与利用的研究现状分析.城市环境与城市生态,1998,11(4):10-14 Wei C.H.,Chen C.H.The analysis of current research on the treatment disposal and utilization of sludge.Urban Environment & Urban Ecology,1998,11(4):10-14(in Chinese)
    [10] Martin H., Gerrit E.Two examples of thermal drying of sewage sludge.Water Science and Technology,1996, 33(12): 235-242
    [11] Nezih K.S.,Vedat P., Guray S. Solar drying in sludge management in Turkey.Renewable Energy,2007, 32(10):1661-1675
    [12] Ruiz T., Wisniewski C., Kaosol T.,et al. Influence of organic content in dewatering and shrinkage of urban residual sludge under controlled atmospheric drying.Process Safety and Environmental Protection, 2007, 85(1):104-110
    [13] Wang C.P., Yu Q.L., Sheng S.X., et al. The performance and environmental impact of the integrated spray drying and incineration demonstration project for dying sludge treatment.Procedia Environmental Sciences, 2012,16(7): 433-442
    [14] Léonard A., Meneses E., Trong E. L., et al. Influence of back mixing on the convective drying of residual sludges in a fixed bed.Water Research,2008, 42(10-11): 2671-2677
    [15] Slim R., Zoughaib A., Clodic D.Modeling of a solar and heat pump sludge drying system. International Journal of Refrigeration,2008,31(7):1156-1168
  • 加载中
WeChat 点击查看大图
计量
  • 文章访问数:  1928
  • HTML全文浏览数:  1404
  • PDF下载数:  861
  • 施引文献:  0
出版历程
  • 收稿日期:  2013-07-26
  • 刊出日期:  2013-11-21
申维真, 张宏伟, 张羽. 城市污泥桨叶式干化优化实验研究[J]. 环境工程学报, 2013, 7(11): 4575-4580.
引用本文: 申维真, 张宏伟, 张羽. 城市污泥桨叶式干化优化实验研究[J]. 环境工程学报, 2013, 7(11): 4575-4580.
shu
Shen Weizhen, Zhang Hongwei, Zhang Yu. Experiments on optimization of sewage sludge drying by paddle dryer[J]. Chinese Journal of Environmental Engineering, 2013, 7(11): 4575-4580.
Citation: Shen Weizhen, Zhang Hongwei, Zhang Yu. Experiments on optimization of sewage sludge drying by paddle dryer[J]. Chinese Journal of Environmental Engineering, 2013, 7(11): 4575-4580.
shu

城市污泥桨叶式干化优化实验研究

  • 1. 北京机电院高技术股份有限公司, 北京 100027
  • 收稿日期:  2013-07-26
基金项目:

北京机电院高技术股份有限公司课题(K1083)

摘要: 桨叶式干化是一种高效的污泥干化处理技术,为了降低污泥含水率达到污泥减量减容效果,同时为后期的工程化应用提供依据和参考,实验采用倾斜盘式桨叶干燥机,以北京市污水处理厂污泥为研究对象,研究了不同滞留时间、污泥供给量、干燥机换热面积等因素对桨叶式干化处理后蒸发速度和污泥含水率的影响,并从处理效率以及与工程化应用数据对比分析等多方面考核,确定最佳工艺运行条件:使用0.5~0.8 MPa的蒸气,蒸发速率达到14~21.8 kg/(m2·h)时,干化处理后污泥含水率<40%。

English Abstract

    全文HTML

参考文献 (15)

返回顶部

目录

/

返回文章
返回

Copyright © 2019 中国科学院生态环境研究中心