高级搜索

利用给水厂污泥预处理畜禽养殖废水

,  , 

downloadPDF

上一篇

下一篇

梁金成, 王昌辉, 裴元生. 利用给水厂污泥预处理畜禽养殖废水[J]. 环境工程学报, 2015, 9(6): 2569-2576. doi: 10.12030/j.cjee.20150606
引用本文: 梁金成, 王昌辉, 裴元生. 利用给水厂污泥预处理畜禽养殖废水[J]. 环境工程学报, 2015, 9(6): 2569-2576. doi: 10.12030/j.cjee.20150606
shu
Liang Jincheng, Wang Changhui, Pei Yuansheng. Use of drinking-water treatment sludge for pre-treatment of livestock wastewater[J]. Chinese Journal of Environmental Engineering, 2015, 9(6): 2569-2576. doi: 10.12030/j.cjee.20150606
Citation: Liang Jincheng, Wang Changhui, Pei Yuansheng. Use of drinking-water treatment sludge for pre-treatment of livestock wastewater[J]. Chinese Journal of Environmental Engineering, 2015, 9(6): 2569-2576. doi: 10.12030/j.cjee.20150606
shu

利用给水厂污泥预处理畜禽养殖废水

  • 1.

    北京师范大学环境学院, 教育部水沙科学重点实验室, 北京 100875

  • 基金项目:

    国家自然科学基金资助项目(51278055,51179008)

  • 中图分类号: X703

Use of drinking-water treatment sludge for pre-treatment of livestock wastewater

  • 1.

    Key Laboratory of Water and Sediment Sciences, Ministry of Education, School of Environment, Beijing Normal University, Beijing 100875, China

  • Fund Project:

  • 摘要: 实验考察了直接回用未脱水的给水厂污泥(undewatered water treatment sludge, UWTS)做絮凝剂进行畜禽养殖废水预处理的可行性.单因素实验结果表明,随着投加量和pH的增加,出水悬浮物浓度(suspended solid,SS)、化学需氧量(chemical oxygen demand,COD)和总磷(total phosphorus,TP)的去除率不断增加;随着快速搅拌速度的提高,UWTS的絮凝效果呈现先增强后减弱的趋势;随着沉淀时间的延长,出水中SS、COD和TP的去除率起初逐渐增大,但15 min后去除率变化不明显.进一步的正交实验分析结果表明,UWTS回用做絮凝剂的最佳反应条件为投加量2 800 mg/L,快速搅拌速度300 r/min,沉淀时间15 min,此时对应的SS、COD和TP的去除率分别为74.8%、54.6%和60.5%.最佳反应条件下的粒径分析结果表明,UWTS的投加使得粒径范围在40~180 μm的颗粒物得到了去除.尽管与商品化絮凝剂相比,UWTS的絮凝效果略差,但是,利用其预处理畜禽养殖废水具有成本优势,因而具有应用潜力.
    Abstract: The feasibility of reusing undewatered water treatment sludge (UWTS) as a flocculant for livestock wastewater pre-treatment was investigated in this work. The results of the single factor experiment demonstrated that the removal rates of suspended solids (SS), chemical oxygen demand(COD) and total phosphorus (TP )increased with the increase of the UWTS dosages and raw wastewater pH. With increasing the rapid mixing speed, their removal rates increased but a further increase would result in a decrease. The removal rates of effluent SS, COD and TP were found to be an increase at earlier stage as the settling time increased, whereas there was no notable increase with increasing the time greater than 15 min. The results of the orthogonal test also showed that the best conditions for flocculation were obtained at UWTS dosage of 2 800 mg/L with the rapid mixing speed at 300 r/min and the settling time of 15 min in which the removal rates of SS, COD and TP were 74.8%, 54.6% and 60.5%, respectively. In addition, the analysis of particle size distribution showed that the particle in size ranging from 40 to 180 μm could be removed significantly. It was found that the flocculation effectiveness of UWTS was not more effective than that of the commercial flocculants, whereas the UWTS for its lower cost indicated a higher potential for pre-treatment of livestock wastewater.
  • 加载中
  • [1] Ippolito J. A., Barbarick K. A., Elliott H. A. Drinking water treatment residuals: A review of recent uses. Journal of Environmental Quality, 2011, 40(1): 1-12
    [2] Boyer T. H., Persaud A., Banerjee P., et al. Comparison of low-cost and engineered materials for phosphorus removal from organic-rich surface water. Water Research, 2011, 45(16): 4803-4814
    [3] Gao Sijia, Wang Changhui, Pei Yuansheng. Comparison of different phosphate species adsorption by ferric and alum water treatment residuals. Journal of Environmental Sciences, 2013, 25(5): 986-992
    [4] Agyin-Birikorang S., Oladeji O. O., O'Connor G. A., et al. Efficacy of drinking-water treatment residual in controlling off-site phosphorus losses: A field study in Florida. Journal of Environmental Quality, 2009, 38(3): 1076-1085
    [5] Zhao X. H., Zhao Y. Q., Kearney P. Use of a novel operation strategy in constructed wetland for high strength wastewater treatment. Water Resource and Environmental Protection (ISWREP), 2011, (4): 3223-3226
    [6] Wang Changhui, Liang Jincheng, Pei Yuansheng, et al. A method for determining the treatment dosage of drinking water treatment residuals for effective phosphorus immobilization in sediments. Ecological Engineering, 2013, 60: 421-427
    [7] Vaezi F., Batebi F. Recovery of iron coagulants from Tehran water-treatment-plant sludge for reusing in textile wastewater treatment. Iranian Journal of Public Health, 2001, 30(3-4): 135-138
    [8] Petruzzelli D., Volpe A., Limoni N., et al. Coagulants removal and recovery from water clarifier sludge. Water Research, 2000, 34(7): 2177-2182
    [9] Babatunde A. O., Zhao Y. Q. Constructive approaches toward water treatment works sludge management: An international review of beneficial reuses. Critical Reviews in Environmental Science & Technology, 2007, 37(2): 129-164
    [10] Guan X. H., Shang C., Yu S. M., et al. Exploratory study on reusing water treatment works sludge to enhance primary sewage treatment. Water Supply, 2004, 4(1): 159-164
    [11] Guan Xiaohong, Chen Guanghao, Shang C. Re-use of water treatment works sludge to enhance particulate pollutant removal from sewage. Water Research, 2005, 39(15): 3433-3440
    [12] Basibuyuk M., Kalat D. G. The use of waterworks sludge for the treatment of vegetable oil refinery industry wastewater. Environmental Technology, 2004, 25(3): 373-380
    [13] 苏杨. 我国集约化畜禽养殖场污染问题研究. 中国生态农业学报, 2006, 14(2): 15-18 Su Yang. Research of countermeasures on waste treating of intensive livestock and poultry farms in China. Chinese Journal of Eco-Agriculture, 2006, 14(2): 15-18(in Chinese)
    [14] Kornboonraksa T., Lee S. H. Factors affecting the performance of membrane bioreactor for piggery wastewater treatment. Bioresource Technology, 2009, 100(12): 2926-2932
    [15] Lee S. H., Iamchaturapatr J., Polprasert C., et al. Application of chemical precipitation for piggery wastewater treatment. Water Science and Technology, 2004, 49(5-6): 381-388
    [16] Kornboonraksa T., Lee H. S., Lee S. H., et al. Application of chemical precipitation and membrane bioreactor hybrid process for piggery wastewater treatment. Bioresource Technology, 2009, 100(6): 1963-1968
    [17] Zheng H., Liao Y., Zheng M., et al. Photoinitiated polymerization of cationic acrylamide in aqueous solution: Synthesis, characterization, and sludge dewatering performance. The Scientific World Journal, 2014
    [18] 国家环境保护总局. 水和废水监测分析方法(第4版). 北京: 中国环境科学出版社, 2002: 346-349
    [19] Gibbons M. K., Gagnon G. A. Understanding removal of phosphate or arsenate onto water treatment residual solids. Journal of Hazardous Materials, 2011, 186(2-3): 1916-1923
    [20] Li Tao, Zhu Zhe, Wang Dongsheng, et al. Characterization of floc size, strength and structure under various coagulation mechanisms. Powder Technology, 2006, 168(2): 104-110
    [21] Yang Y., Zhao Y. Q., Babatunde A. O., et al. Characteristics and mechanisms of phosphate adsorption on dewatered alum sludge. Separation and Purification Technology, 2006, 51(2): 193-200
    [22] Sheng Wenyan, Peng X. F., Lee D. J., et al. Coagulation of particles through rapid mixing. Drying Technology, 2006, 24(10): 1271-1276
    [23] Lee S. Performance evaluation of chemical precipitation and upflow anaerobic floating filter hybrid processes for piggery wastewater treatment. Desalination and Water Treatment, 2011, 32(1-3): 397-403
    [24] Chu Wei. Lead metal removal by recycled alum sludge. Water Research, 1999, 33(13): 3019-3025
  • 加载中
WeChat 点击查看大图
计量
  • 文章访问数:  1679
  • HTML全文浏览数:  1123
  • PDF下载数:  638
  • 施引文献:  0
出版历程
  • 收稿日期:  2014-05-13
  • 刊出日期:  2015-06-09
梁金成, 王昌辉, 裴元生. 利用给水厂污泥预处理畜禽养殖废水[J]. 环境工程学报, 2015, 9(6): 2569-2576. doi: 10.12030/j.cjee.20150606
引用本文: 梁金成, 王昌辉, 裴元生. 利用给水厂污泥预处理畜禽养殖废水[J]. 环境工程学报, 2015, 9(6): 2569-2576. doi: 10.12030/j.cjee.20150606
shu
Liang Jincheng, Wang Changhui, Pei Yuansheng. Use of drinking-water treatment sludge for pre-treatment of livestock wastewater[J]. Chinese Journal of Environmental Engineering, 2015, 9(6): 2569-2576. doi: 10.12030/j.cjee.20150606
Citation: Liang Jincheng, Wang Changhui, Pei Yuansheng. Use of drinking-water treatment sludge for pre-treatment of livestock wastewater[J]. Chinese Journal of Environmental Engineering, 2015, 9(6): 2569-2576. doi: 10.12030/j.cjee.20150606
shu

利用给水厂污泥预处理畜禽养殖废水

  • 1. 北京师范大学环境学院, 教育部水沙科学重点实验室, 北京 100875
  • 收稿日期:  2014-05-13
基金项目:

国家自然科学基金资助项目(51278055,51179008)

摘要: 实验考察了直接回用未脱水的给水厂污泥(undewatered water treatment sludge, UWTS)做絮凝剂进行畜禽养殖废水预处理的可行性.单因素实验结果表明,随着投加量和pH的增加,出水悬浮物浓度(suspended solid,SS)、化学需氧量(chemical oxygen demand,COD)和总磷(total phosphorus,TP)的去除率不断增加;随着快速搅拌速度的提高,UWTS的絮凝效果呈现先增强后减弱的趋势;随着沉淀时间的延长,出水中SS、COD和TP的去除率起初逐渐增大,但15 min后去除率变化不明显.进一步的正交实验分析结果表明,UWTS回用做絮凝剂的最佳反应条件为投加量2 800 mg/L,快速搅拌速度300 r/min,沉淀时间15 min,此时对应的SS、COD和TP的去除率分别为74.8%、54.6%和60.5%.最佳反应条件下的粒径分析结果表明,UWTS的投加使得粒径范围在40~180 μm的颗粒物得到了去除.尽管与商品化絮凝剂相比,UWTS的絮凝效果略差,但是,利用其预处理畜禽养殖废水具有成本优势,因而具有应用潜力.

English Abstract

    全文HTML

参考文献 (24)

返回顶部

目录

/

返回文章
返回

Copyright © 2019 中国科学院生态环境研究中心