再生水中硫酸盐还原菌对Q235碳钢的腐蚀行为

万剑梅; 田一梅; 郑波

doi:10.12030/j.cjee.20150717

环境工程学报

再生水中硫酸盐还原菌对Q235碳钢的腐蚀行为

, ,

万剑梅, 田一梅, 郑波. 再生水中硫酸盐还原菌对Q235碳钢的腐蚀行为[J]. 环境工程学报, 2015, 9(7): 3177-3183. doi: 10.12030/j.cjee.20150717

引用本文:

万剑梅, 田一梅, 郑波. 再生水中硫酸盐还原菌对Q235碳钢的腐蚀行为[J]. 环境工程学报, 2015, 9(7): 3177-3183. doi: 10.12030/j.cjee.20150717

Wan Jianmei, Tian Yimei, Zheng Bo. Corrosion behavior of Q235 carbon steel in sulfate reducing bacteria from reclaimed water[J]. Chinese Journal of Environmental Engineering, 2015, 9(7): 3177-3183. doi: 10.12030/j.cjee.20150717

Citation:

Wan Jianmei, Tian Yimei, Zheng Bo. Corrosion behavior of Q235 carbon steel in sulfate reducing bacteria from reclaimed water[J]. Chinese Journal of Environmental Engineering, 2015, 9(7): 3177-3183. doi: 10.12030/j.cjee.20150717

再生水中硫酸盐还原菌对Q235碳钢的腐蚀行为

1.
天津大学环境科学与工程学院, 天津 300072
基金项目:
国家"水体污染控制与治理"科技重大专项(2009ZX07317-005)
中图分类号: TG172.5

Corrosion behavior of Q235 carbon steel in sulfate reducing bacteria from reclaimed water

1.
School of Environmental Science and Engineering, Tianjin University, Tianjin 300072, China
Fund Project:

摘要: 再生水回用是缓解我国水资源危机的有效途径。然而由于再生水营养丰富,微生物大量繁殖成为其回用的关键问题。从以再生水作为补充水源的3倍循环冷却水中分离纯化出硫酸盐还原菌(SRB),在实验室条件下,采用环境扫描电镜(SEM)、原子力显微镜(AFM)、线性极化电阻、极化曲线、电化学阻抗谱(EIS)等方法研究了SRB对Q235碳钢的腐蚀行为。结果表明,浸泡初期SRB生物膜抑制碳钢的腐蚀,随后促进碳钢的腐蚀,表现为点蚀,随着浸泡时间的延长,腐蚀速率逐渐下降并趋于稳定,但碳钢表面的粗糙度和腐蚀坑深却逐渐增大。7 d时碳钢表面形成完整的生物膜,随后扩散作用成为电极反应控制的主导。
- 再生水 /
- Q235碳钢 /
- 微生物腐蚀 /
- 原子力显微镜 /
- 线性极化电阻 /
- 电化学阻抗谱
Abstract: Reclaimed water reuse is an effective way to relieve water resources crisis.However,because of its rich nutrition,microbial problems become the key of its reuse.Sulfate reducing bacteria(SRB) was separated and purificated from three times cooling water suppled by reclaimed water.Under laboratory conditions,corrosion behavior of Q235 carbon steel in sulfate reducing bacteria was studied by scanning electron microscope(SEM),atomic force microscope(AFM),linear polarization resistance (LCP),electrochemical impedance spectroscopy(EIS).The results show that SRB bacteria first inhibits the corrosion of carbon steel,then accelerates the corrosion,characterized by pitting.With the extension of soaking time,the corrosion rate gradually decreases and tends to be stable,but the roughness and corrosion pit depth on the surface of the carbon steel increases gradually.7 days later a complete biological membrane forms,then the diffusion becomes the dominant of electrode reaction control.
- reclaimed water /
- Q235 carbon steel /
- microbiologically induced corrosion /
- AFM /
- linear polarization resistance /
- EIS

[1]	武东文,刘政修.城市再生水在燃煤热电厂循环冷却水系统中的应用.华北电力技术,2009,5(4):31-34 Wu Dongwen,Liu Zhengxiu.Using municipal recycled water in cycling cooling water system of coal burning power plant.North China Electric Power,2009,5(4):31-34(in Chinese)
[2]	Kuang Fei,Wang Jia,Yan Li,et al.Effects of sulfate-reducing bacteria on the corrosion behavior of carbon steel.Electrochimica Acta,2007,52(20):6084-6088
[3]	Raoa T.S.,Sairamb T.N.,Viswanathan B.,et al.Carbon steel corrosion by iron oxidising and sulphate reducing bacteria in a freshwater cooling system.Corrosion Science,2000,42(8):1417-1431
[4]	Yuan Shaojun,Liang Bin,Zhao Yu,et al.Surface chemistry and corrosion behaviour of 304 stainless steel in simulated seawater containing inorganic sulphide and sulphate-reducing bacteria.Corrosion Science,2013,74:353-366
[5]	Duan Jizhou,Wu Suru,Zhang Xiaojun,et al.Corrosion of carbon steel influenced by anaerobic biofilm in natural seawater.Electrochimica Acta,2008,54(1):22-28
[6]	Wang Haibo,Hu Chun,Hu Xuexiang,et al.Effects of disinfectant and biofilm on the corrosion of cast iron pipes in a reclaimed water distribution system.Water Research,2012,46(4):1070-1078
[7]	李进,许兆义,李久义,等.再生水环境中304不锈钢生物膜腐蚀电化学特征.物理化学学报,2010,26(10):2638-2646 Li Jin,Xu Zhaoyi,Li Jiuyi,et al.Characteristics of the microbiologically influenced corrosion of 304 stainless steel in reclaimed water environment.Acta Physico-Chimica Sinica,2010,26(10):2638-2646(in Chinese)
[8]	张静,李进,王开强,等.再生水中弗氏柠檬酸杆菌生物膜特性研究.环境化学,2011,30(10):1687-1694 Zhang Jing,Li Jin,Wang Kaiqiang,et al.Study on the characteristic of Citrobacter freundii biofilm in reclaimed water.Environmental Chemistry,2011,30(10):1687-1694(in Chinese)
[9]	Javaherdashti R.Modeling microbiologically influenced corrosion of N-80 carbon steel by fuzzy calculus.Metallurgical and Materials Transactions A,2004,35(7):2051-2056
[10]	Postgate J.R.The Sulphate-Reducing Bacteria.UK:Cambridge University Press,1979:26
[11]	Xu K.,Dexter S.C.,Luther G.W.III.Voltammetric microelectrodes for biocorrosion studies.Corrosion Science,1998,54(10):814-823
[12]	Marcus P.Surface science approach of corrosion phenomena.Electrochimica Acta,1998,43(1-2):109-118
[13]	Stadler R.,Wei L.,Fürbeth W.,et al.Influence of bacterial exopolymers on cell adhesion of Desulfovibrio vulgaris on high alloyed steel:Corrosion inhibition by extracellular polymeric substances (EPS).Materials and Corrosion,2010,61(12):1008-1015
[14]	Wagner P.,Little B.Impact of alloying on microbiologically influenced corrosion-a review.Materials Performance,1993,32(9):65-68
[15]	Ray R.I.,Little B.J.,Lee J.S.The influence of marine biofilms on corrosion:A concise review.Electrochimica Acta,2008,54(1):2-7
[16]	赵晓栋,吴鹏,姜江,等.硫酸盐还原菌对海泥中Q235钢腐蚀界面的影响.材料研究学报,2007,21(3):230-234 Zhao Xiaodong,Wu Peng,Jiang Jing,et al.Study of effect of sulfate-reducing bacteria on corrosion interface between Q235 steel and sea mud.Chinese Journal of Materials Research,2007,21(3):230-234(in Chinese)
[17]	AlAbbas F.M.,Williamson C.,Bhola S.M.,et al.Influence of sulfate reducing bacterial biofilm on corrosion behavior of low-alloy,high-strength steel (API-5L X80).International Biodeterioration & Biodegradation,2013,78:34-42
[18]	Kuhr V.Study of electrochemical interactions of SRB.Corrosion Science,1984,18(9):147-155
[19]	Castaneda H.,Benetton X.D.SRB-biofilm influence in active corrosion sites formed at the steel-electrolyte interface when exposed to artificial seawater conditions.Corrosion Science,2008,50(4):1169-1183
[20]	李付绍,安茂忠,刘光洲,等.硫酸盐还原菌的含硫代谢产物在加速碳钢腐蚀中的作用.无机化学学报,2009,25(1):13-18 Li Fuzhao,An Maozhong,Liu Guangzhou,et al.Roles of sulfur-containing metabolites by SRB in accelerating corrosion of carbon steel.Chinese Journal of Inorganic Chemistry,2009,25(1):13-18(in Chinese)
[21]	Yu Lin,Duan Jizhou,Du Xiangqian,et al.Accelerated anaerobic corrosion of electroactive sulfate-reducing bacteria by electrochemical impedance spectroscopy and chronoamperometry.Electrochemistry Communications,2013,26:101-104
[22]	曹楚南,张鉴清.电化学阻抗谱导论.北京:科学出版社,2002:27-84
[23]	张治国,吴明,陈旭.侵蚀性阴离子对A3钢腐蚀电化学行为的影响.腐蚀与防护,2011,32(8):609-612 Zhang Zhiguo,Wu Ming,Chen Xu.Effect of aggressive anions on corrision behavior of A3 steel.Corrosion and Protection,2011,32(8):609-612(in Chinese)

点击查看大图

计量

文章访问数: 1975
HTML全文浏览数: 1498
PDF下载数: 550
施引文献: 0

万剑梅, 田一梅, 郑波. 再生水中硫酸盐还原菌对Q235碳钢的腐蚀行为[J]. 环境工程学报, 2015, 9(7): 3177-3183. doi: 10.12030/j.cjee.20150717

引用本文:

万剑梅, 田一梅, 郑波. 再生水中硫酸盐还原菌对Q235碳钢的腐蚀行为[J]. 环境工程学报, 2015, 9(7): 3177-3183. doi: 10.12030/j.cjee.20150717

Citation:

再生水中硫酸盐还原菌对Q235碳钢的腐蚀行为

1. 天津大学环境科学与工程学院, 天津 300072

收稿日期: 2014-06-26

基金项目:

国家"水体污染控制与治理"科技重大专项(2009ZX07317-005)

关键词:

摘要: 再生水回用是缓解我国水资源危机的有效途径。然而由于再生水营养丰富,微生物大量繁殖成为其回用的关键问题。从以再生水作为补充水源的3倍循环冷却水中分离纯化出硫酸盐还原菌(SRB),在实验室条件下,采用环境扫描电镜(SEM)、原子力显微镜(AFM)、线性极化电阻、极化曲线、电化学阻抗谱(EIS)等方法研究了SRB对Q235碳钢的腐蚀行为。结果表明,浸泡初期SRB生物膜抑制碳钢的腐蚀,随后促进碳钢的腐蚀,表现为点蚀,随着浸泡时间的延长,腐蚀速率逐渐下降并趋于稳定,但碳钢表面的粗糙度和腐蚀坑深却逐渐增大。7 d时碳钢表面形成完整的生物膜,随后扩散作用成为电极反应控制的主导。

English Abstract

Corrosion behavior of Q235 carbon steel in sulfate reducing bacteria from reclaimed water

1. School of Environmental Science and Engineering, Tianjin University, Tianjin 300072, China

Received Date: 2014-06-26

Fund Project:

Keywords:

Abstract: Reclaimed water reuse is an effective way to relieve water resources crisis.However,because of its rich nutrition,microbial problems become the key of its reuse.Sulfate reducing bacteria(SRB) was separated and purificated from three times cooling water suppled by reclaimed water.Under laboratory conditions,corrosion behavior of Q235 carbon steel in sulfate reducing bacteria was studied by scanning electron microscope(SEM),atomic force microscope(AFM),linear polarization resistance (LCP),electrochemical impedance spectroscopy(EIS).The results show that SRB bacteria first inhibits the corrosion of carbon steel,then accelerates the corrosion,characterized by pitting.With the extension of soaking time,the corrosion rate gradually decreases and tends to be stable,but the roughness and corrosion pit depth on the surface of the carbon steel increases gradually.7 days later a complete biological membrane forms,then the diffusion becomes the dominant of electrode reaction control.

全文HTML

参考文献 (23)

下载: 全尺寸图片幻灯片

返回文章

用微信扫码二维码

分享至好友和朋友圈

再生水中硫酸盐还原菌对Q235碳钢的腐蚀行为

Corrosion behavior of Q235 carbon steel in sulfate reducing bacteria from reclaimed water

计量

出版历程

再生水中硫酸盐还原菌对Q235碳钢的腐蚀行为

English Abstract

Corrosion behavior of Q235 carbon steel in sulfate reducing bacteria from reclaimed water

全文HTML

目录