常温常压KBH4还原法快速脱除水煤浆中的硫

沈亚飞; 孙同华; 贾金平; 刘训悦

环境化学

, , ,

沈亚飞, 孙同华, 贾金平, 刘训悦. 常温常压KBH4还原法快速脱除水煤浆中的硫[J]. 环境化学, 2012, 31(5): 697-701.

引用本文:

沈亚飞, 孙同华, 贾金平, 刘训悦. 常温常压KBH4还原法快速脱除水煤浆中的硫[J]. 环境化学, 2012, 31(5): 697-701.

SHEN Yafei, SUN Tonghua, JIA Jinping, LIU Xunyue. Rapid sulfur removal from coal water slurry by potassium borohydride reduction under ambient conditions[J]. Environmental Chemistry, 2012, 31(5): 697-701.

Citation:

SHEN Yafei, SUN Tonghua, JIA Jinping, LIU Xunyue. Rapid sulfur removal from coal water slurry by potassium borohydride reduction under ambient conditions[J]. Environmental Chemistry, 2012, 31(5): 697-701.

常温常压KBH4还原法快速脱除水煤浆中的硫

1.
上海交通大学环境科学与工程学院, 上海, 200240;
2.
浙江大学原子核农业科学研究所, 杭州, 310029
基金项目:
国家高新技术研究发展计划 (863 计划, 2009AA062603)资助.

Rapid sulfur removal from coal water slurry by potassium borohydride reduction under ambient conditions

1.
Shanghai Jiaotong University, School of Environmental Science & Engineering, Shanghai, 200240, China;
2.
Zhejiang University, Institute of Nuclear Agricultural Science, Hangzhou, 310029, China
Fund Project:

摘要: 使用KBH4还原法脱除水煤浆中的硫.在常温常压,KBH4浓度为2.0 mmol·L-1、煤炭粒径109 μm、处理时间10 min、搅拌速度为200 r·min-1的条件下,低硫水煤浆中煤炭的总脱硫率可以达到43.0%.而且硫酸盐硫的脱除率约47.8%,黄铁矿硫的脱除率约55.4%;同时有机硫的脱除率约23.9%.硼氢化钾还原法相比其它传统化学脱硫方法,对有机硫和无机硫脱除均有作用,试剂用量少,反应条件温和,脱硫速度快,热值的损耗小,处理后水煤浆中煤炭的热值有所提高,起燃温度降低.
- 水煤浆 /
- 硼氢化钾 /
- 还原脱硫
Abstract: The present work employed KBH4 reduction to remove sulfur in coal water slurry (CWS) for the first time. Under the conditions of normal pressure and temperature, 2.0 mmol·L-1 KBH4, 109 μm coal particle, 10 min treatment time and 200 r·min-1 shaking rate, the total sulfur reduction of low-sulfur CWS was about 43.0%. The removal efficiency of sulfate sulfur was 47.8%, and the removal efficiency of pyrite sulfur was 55.4%. Besides, organic sulfur reduction was 23.9%. Compared with traditional chemical desulfurization methods, the current method was effective in removing both organic and inorganic sulfurs. It also used less reagent, mild reaction conditions, short treatment time, and less loss of calorific value. After the treatment, calorific value of CWS got improved, and ignition temperature was reduced.
- coal water slurry /
- potassium borohydride /
- reductive desulfurization

[1]	王建龙. 现代环境生物技术 [M]. 北京:清华大学出版社, 2001, 25 (1): 318-328
[2]	李学亮. 国外煤炭脱硫降灰技术的发展趋向 [J]. 中国煤炭, 2000, 26 (7): 61- 63
[3]	丁智华. 简述电厂烟气脱硫的几种方法及脱硫误区 [J]. 中国科技博览, 2009, 28:121
[4]	张威, 李文军. 煤的化学氧化脱硫技术及其研究 [J]. 煤化工, 2006, 36(3): 37-39
[5]	曹晏, 张尚武, 李斌, 等. 阳泉高硫无烟煤热化学法预脱硫的试验考察 [J]. 燃料化学学报, 2001, 29(4): 329-333
[6]	陈皓侃, 李保庆, 张碧江. 高硫煤加氢热解脱硫的研究. Ⅱ反应条件对煤加氢热解脱硫影响 [J]. 燃料化学学报, 1997, 25(5): 404-409
[7]	De Souza M V N,Vasconcelos T R A. Recent methodologies mediated by sodium borohydride in the reduction of different classes of compounds [J]. Applied Organometallic Chemistry, 2006, 20(11): 798-810
[8]	Li Z L, Sun T H, Jia J P. An extremely rapid, convenient and mild coal desulfurization new process: Sodium borohydride reduction [J]. Fuel Processing Technology, 2010, 91: 1162-1167
[9]	Liu B H, Li Z P, Suda S. Thermal properties of alkaline sodium borohydride solutions [J].Thermochemical Acta,2008, 471: 103-105
[10]	Rong W R, Qiu D R. Decomposition of borohydride solution and stabilization mechanism of NaOH [J].Journal of Fudan University (Natural Science),1998, 37: 276-278
[11]	Liu K C, Yang J, Jia J P, et al. Desulphurization of coal via low temperature atmospheric alkaline oxidation [J].Chemosphere.2008, 71: 183-188
[12]	Baruah B P, Khare P. Desulfurization of oxidized Indian coals with solvent extraction and alkali treatment [J].Energy & Fuels, 2007, 21: 2156-2164

点击查看大图

计量

文章访问数: 1043
HTML全文浏览数: 1023
PDF下载数: 495
施引文献: 0

沈亚飞, 孙同华, 贾金平, 刘训悦. 常温常压KBH4还原法快速脱除水煤浆中的硫[J]. 环境化学, 2012, 31(5): 697-701.

引用本文:

沈亚飞, 孙同华, 贾金平, 刘训悦. 常温常压KBH4还原法快速脱除水煤浆中的硫[J]. 环境化学, 2012, 31(5): 697-701.

Citation:

常温常压KBH4还原法快速脱除水煤浆中的硫

1. 上海交通大学环境科学与工程学院, 上海, 200240;
2. 浙江大学原子核农业科学研究所, 杭州, 310029

收稿日期: 2011-09-21

基金项目:

国家高新技术研究发展计划 (863 计划, 2009AA062603)资助.

关键词:

水煤浆 /
硼氢化钾 /
还原脱硫

摘要: 使用KBH4还原法脱除水煤浆中的硫.在常温常压,KBH4浓度为2.0 mmol·L-1、煤炭粒径109 μm、处理时间10 min、搅拌速度为200 r·min-1的条件下,低硫水煤浆中煤炭的总脱硫率可以达到43.0%.而且硫酸盐硫的脱除率约47.8%,黄铁矿硫的脱除率约55.4%;同时有机硫的脱除率约23.9%.硼氢化钾还原法相比其它传统化学脱硫方法,对有机硫和无机硫脱除均有作用,试剂用量少,反应条件温和,脱硫速度快,热值的损耗小,处理后水煤浆中煤炭的热值有所提高,起燃温度降低.

English Abstract

Rapid sulfur removal from coal water slurry by potassium borohydride reduction under ambient conditions

1. Shanghai Jiaotong University, School of Environmental Science & Engineering, Shanghai, 200240, China;
2. Zhejiang University, Institute of Nuclear Agricultural Science, Hangzhou, 310029, China

Received Date: 2011-09-21

Fund Project:

Keywords:

Abstract: The present work employed KBH4 reduction to remove sulfur in coal water slurry (CWS) for the first time. Under the conditions of normal pressure and temperature, 2.0 mmol·L-1 KBH4, 109 μm coal particle, 10 min treatment time and 200 r·min-1 shaking rate, the total sulfur reduction of low-sulfur CWS was about 43.0%. The removal efficiency of sulfate sulfur was 47.8%, and the removal efficiency of pyrite sulfur was 55.4%. Besides, organic sulfur reduction was 23.9%. Compared with traditional chemical desulfurization methods, the current method was effective in removing both organic and inorganic sulfurs. It also used less reagent, mild reaction conditions, short treatment time, and less loss of calorific value. After the treatment, calorific value of CWS got improved, and ignition temperature was reduced.

全文HTML

参考文献 (12)

下载: 全尺寸图片幻灯片

返回文章

用微信扫码二维码

分享至好友和朋友圈

常温常压KBH4还原法快速脱除水煤浆中的硫

Rapid sulfur removal from coal water slurry by potassium borohydride reduction under ambient conditions

计量

出版历程

常温常压KBH4还原法快速脱除水煤浆中的硫

English Abstract

Rapid sulfur removal from coal water slurry by potassium borohydride reduction under ambient conditions

全文HTML

目录