高级搜索

印染废水生化出水高锰酸钾强化混凝深度处理溶解性有机物的去除特性

,  ,  ,  ,  , 

downloadPDF

上一篇

下一篇

李暮, 孙贤波, 刘勇弟, 钱飞跃, 李欣珏, 李新. 印染废水生化出水高锰酸钾强化混凝深度处理溶解性有机物的去除特性[J]. 环境化学, 2012, 31(12): 1878-1885.
引用本文: 李暮, 孙贤波, 刘勇弟, 钱飞跃, 李欣珏, 李新. 印染废水生化出水高锰酸钾强化混凝深度处理溶解性有机物的去除特性[J]. 环境化学, 2012, 31(12): 1878-1885.
shu
LI Mu, SUN Xianbo, LIU Yongdi, QIAN Feiyue, LI Xinjue, LI Xin. Removal characteristic of dissolved organic matters in bio-treated effluents of dyeing and textile wastewater by potassium permanganate enhanced coagulation[J]. Environmental Chemistry, 2012, 31(12): 1878-1885.
Citation: LI Mu, SUN Xianbo, LIU Yongdi, QIAN Feiyue, LI Xinjue, LI Xin. Removal characteristic of dissolved organic matters in bio-treated effluents of dyeing and textile wastewater by potassium permanganate enhanced coagulation[J]. Environmental Chemistry, 2012, 31(12): 1878-1885.
shu

印染废水生化出水高锰酸钾强化混凝深度处理溶解性有机物的去除特性

  • 1.

    华东理工大学资源与环境工程学院, 上海, 200237

  • 基金项目:

    国家863计划重点项目课题资助(2009AA063904)资助.

Removal characteristic of dissolved organic matters in bio-treated effluents of dyeing and textile wastewater by potassium permanganate enhanced coagulation

  • 1.

    School of Resources and Environmental Engineering, East China University of Science and Technology, Shanghai, 200237, China

  • Fund Project:

  • 摘要: 采用高锰酸钾预氧化,强化某印染废水生化出水铁盐混凝深度处理溶解性有机物(DOM),考察了高锰酸钾强化混凝对印染废水生化出水中DOM的去除特性并为优化混凝深度处理工艺提供理论参考.在最优投加条件下,高锰酸钾强化混凝处理提高了DOM色度的去除效果,以美国染料生产协会色度值(ADMI7.6)表征时为84%,出水ADMI7.6值较单独混凝处理降低了43%.但以溶解性有机碳(DOC)表征时去除率基本保持不变,为55%.通过XAD-8/XAD-4 吸附树脂分离技术和分子量分布分析发现,高锰酸钾强化混凝处理通过有效去除疏水性和弱疏水性DOM色度降低了出水的色度.同时,出水中亲水性和小分子DOM(MW < 1 kDa)较单独混凝处理分别增加了34%和15%,导致了DOM去除率以DOC表征时无显著改善.采用三维荧光光谱技术定性分析表明,引起色度的可见类富里酸和类腐殖酸物质被进一步去除使出水色度降低,此时出水中增多的小分子亲水性DOM主要为类蛋白质和富里酸物质.因此,高锰酸钾强化混凝处理过程仍需与其它能去除亲水性、小分子量DOM (MW < 1 kDa) 的处理工艺结合,以提高总体去除效率.
    Abstract: In this paper, the effectiveness of potassium permanganate-enhanced coagulation process for dissolved organic matter (DOM) removal in the bio-effluent of dyeing and textile wastewater was investigated. The removal behaviors of DOM were characterized to support the optimization of coagulation treatment. Under the optimal dosing conditions, the color removal efficiency of potassium permanganate-enhanced coagulation treatment by the American Dyeing Manufactures Institute value (ADMI7.6) was improved to 84%, and the ADMI7.6 value of effluents after enhanced coagulation was 43% lower than that of ferric coagulation alone. However, the DOM removal of enhanced coagulation in term of DOC barely changed, about 55% of DOC was eliminated. Compared with the treatment of ferric coagulation, the results of XAD-8/XAD-4 tandem resin fractionation and molecular weight (MW) distribution measurements demonstrated that the removal of large-MW hydrophobics and transphilics were improved after enhanced coagulation, which resulted in the decrease of effluent color. Moreover, the hydrophilics and low-MW (<1 kDa) organics in the effluent of enhanced coagulation were increased by 34% and 15%, respectively, which were the main reasons for no significant improvement of DOC removal obtained. Qualitative analysis on DOM with three-dimensional excitation emission matrix fluorescence spectroscopy (3-DEEMs) indicated that fulvic-like and humic-like organics were further removed during enhanced coagulation process. Meanwhile, the increased low-MW hydrophilics were protein-like and fulvic-like organics dominantly. Potassium permanganate-enhanced coagulation needs to be combined with additional treatment steps that excel in removing the remaining DOM (mostly MW<1 kDa, hydrophilics) to produce a high overall removal performance.
  • 加载中
  • [1] 毛艳梅, 奚旦立, 杨晓波. 印染废水深度处理技术及回用的现状和发展[J]. 印染, 2005(8): 46-48
    [2] El-Gohary F, Tawfik A. Decolorization and cod reduction of disperse and reactive dyes wastewater using chemical-coagulation followed by sequential batch reactor (SBR) process[J]. Desalination, 2009, 249(3): 1159-1164
    [3] Kumar P, Prasad B, Mishra I, et al. Decolorization and cod reduction of dyeing wastewater from a cotton textile mill using thermolysis and coagulation[J]. Journal of hazardous materials, 2008, 153(1/2): 635-645
    [4] Kim T H, Park C, Yang J, et al. Comparison of disperse and reactive dye removals by chemical coagulation and fenton oxidation[J]. Journal of hazardous materials, 2004, 112(1/2): 95-103
    [5] 李暮, 钱飞跃, 李欣珏,等. 印染废水生化出水中有机污染物特性及在硫酸镁混凝过程中的去除行为研究[J]. 环境化学, 2012, 31(1): 88-93
    [6] 任芝军, 孙勇, 刘慧,等. 高锰酸盐复合药剂强化混凝工艺研究[J]. 水处理技术, 2008, 34(2): 41-44
    [7] Chen J J, Yeh H H, Tseng I. Potassium permanganate as an alternative preoxidant for enhancing algal coagulation-pilot and bench scale studies[J]. Environmental Technology, 2008, 29(7): 721-729
    [8] 赵春禄, 寻涛, 晗桢. 高锰酸钾预氧化并复合高岭土与聚合氯化铝(PAC)絮凝去除水中颤藻[J]. 环境化学, 2009, 28(6): 846-849
    [9] Lee E S, Schwartz F W. Characteristics and applications of controlled-release KMnO4 for groundwater remediation[J]. Chemosphere, 2007, 66(11): 2058-2066
    [10] Li N, Fan M, Van Leeuwen J, et al. Oxidation of AS (Ⅲ) by potassium permanganate[J]. Journal of Environmental Sciences, 2007, 19(7): 783-786
    [11] Kao C, Chou M, Fang W, et al. Regulating colored textile wastewater by 3/31 wavelength admi methods in Taiwan[J]. Chemosphere, 2001, 44(5): 1055-1063
    [12] Hao O, Kim H, Chiang P. Decolorization of wastewater[J]. Critical Reviews in Environmental Science and Technology, 1999, 30(4): 449-505
    [13] 钱飞跃, 孙贤波, 刘勇弟,等. 工业废水色度的测定方法研究[J]. 工业水处理, 2011, 31(9): 72-75
    [14] 龚剑丽, 刘勇弟, 孙贤波,等. 城市污水二级生化出水中有机污染物特性表征[J]. 环境化学, 2007, 26(5): 706-707
    [15] 龚剑丽, 刘勇弟, 孙贤波,等. 生化出水中各类有机污染物的特性及在混凝处理过程中的行为[J]. 华东理工大学学报: 自然科学版, 2008, 34(1): 91-95
    [16] Leenheer J, Croué J. Characterizing aquatic dissolved organic matter[J]. Environmental Science & Technology, 2003, 37(1): 18-26
    [17] Chen W, Westerhoff P, Leenheer J A, et al. Fluorescence excitation-emission matrix regional integration to quantify spectra for dissolved organic matter[J]. Environmental Science & Technology, 2003, 37(24): 5701-5710
    [18] Matilainen A, Lindqvist N, Tuhkanen T. Comparison of the effiency of aluminium and ferric sulphate in the removal of natural organic matter during drinking water treatment process[J]. Environmental Technology, 2005, 26(8): 867-876
    [19] 王丽莎, 胡洪营, 藤江幸一. 污水氯和二氧化氯消毒过程中溶解性有机物变化的三维荧光光谱解析[J]. 环境科学, 2007, 28(7): 1524-1528
    [20] Chen J, Leboeuf E J, Dai S, et al. Fluorescence spectroscopic studies of natural organic matter fractions[J]. Chemosphere, 2003, 50(5): 639-647
    [21] 陈东, 刘文清, 张玉钧,等. 污染水体溶解性有机物诱导荧光淬灭特性的实验研究[J]. 光谱学与光谱分析, 2006, 26(12): 2283-2286
  • 加载中
WeChat 点击查看大图
计量
  • 文章访问数:  1160
  • HTML全文浏览数:  1105
  • PDF下载数:  281
  • 施引文献:  0
出版历程
  • 收稿日期:  2012-02-16
李暮, 孙贤波, 刘勇弟, 钱飞跃, 李欣珏, 李新. 印染废水生化出水高锰酸钾强化混凝深度处理溶解性有机物的去除特性[J]. 环境化学, 2012, 31(12): 1878-1885.
引用本文: 李暮, 孙贤波, 刘勇弟, 钱飞跃, 李欣珏, 李新. 印染废水生化出水高锰酸钾强化混凝深度处理溶解性有机物的去除特性[J]. 环境化学, 2012, 31(12): 1878-1885.
shu
LI Mu, SUN Xianbo, LIU Yongdi, QIAN Feiyue, LI Xinjue, LI Xin. Removal characteristic of dissolved organic matters in bio-treated effluents of dyeing and textile wastewater by potassium permanganate enhanced coagulation[J]. Environmental Chemistry, 2012, 31(12): 1878-1885.
Citation: LI Mu, SUN Xianbo, LIU Yongdi, QIAN Feiyue, LI Xinjue, LI Xin. Removal characteristic of dissolved organic matters in bio-treated effluents of dyeing and textile wastewater by potassium permanganate enhanced coagulation[J]. Environmental Chemistry, 2012, 31(12): 1878-1885.
shu

印染废水生化出水高锰酸钾强化混凝深度处理溶解性有机物的去除特性

  • 1. 华东理工大学资源与环境工程学院, 上海, 200237
  • 收稿日期:  2012-02-16
基金项目:

国家863计划重点项目课题资助(2009AA063904)资助.

摘要: 采用高锰酸钾预氧化,强化某印染废水生化出水铁盐混凝深度处理溶解性有机物(DOM),考察了高锰酸钾强化混凝对印染废水生化出水中DOM的去除特性并为优化混凝深度处理工艺提供理论参考.在最优投加条件下,高锰酸钾强化混凝处理提高了DOM色度的去除效果,以美国染料生产协会色度值(ADMI7.6)表征时为84%,出水ADMI7.6值较单独混凝处理降低了43%.但以溶解性有机碳(DOC)表征时去除率基本保持不变,为55%.通过XAD-8/XAD-4 吸附树脂分离技术和分子量分布分析发现,高锰酸钾强化混凝处理通过有效去除疏水性和弱疏水性DOM色度降低了出水的色度.同时,出水中亲水性和小分子DOM(MW < 1 kDa)较单独混凝处理分别增加了34%和15%,导致了DOM去除率以DOC表征时无显著改善.采用三维荧光光谱技术定性分析表明,引起色度的可见类富里酸和类腐殖酸物质被进一步去除使出水色度降低,此时出水中增多的小分子亲水性DOM主要为类蛋白质和富里酸物质.因此,高锰酸钾强化混凝处理过程仍需与其它能去除亲水性、小分子量DOM (MW < 1 kDa) 的处理工艺结合,以提高总体去除效率.

English Abstract

    全文HTML

参考文献 (21)

返回顶部

目录

/

返回文章
返回

Copyright © 2019 中国科学院生态环境研究中心