高级搜索

曝气吹脱法用于牛场沼液污染物的去除

,  , 

downloadPDF

上一篇

下一篇

龚川南, 陈玉成, 黄磊. 曝气吹脱法用于牛场沼液污染物的去除[J]. 环境工程学报, 2016, 10(5): 2291-2296. doi: 10.12030/j.cjee.201504083
引用本文: 龚川南, 陈玉成, 黄磊. 曝气吹脱法用于牛场沼液污染物的去除[J]. 环境工程学报, 2016, 10(5): 2291-2296. doi: 10.12030/j.cjee.201504083
shu
Gong Chuannan, Chen Yucheng, Huang Lei. Pollutants removal characteristics by air stripping with aeration treating biogas slurry of cattle manure[J]. Chinese Journal of Environmental Engineering, 2016, 10(5): 2291-2296. doi: 10.12030/j.cjee.201504083
Citation: Gong Chuannan, Chen Yucheng, Huang Lei. Pollutants removal characteristics by air stripping with aeration treating biogas slurry of cattle manure[J]. Chinese Journal of Environmental Engineering, 2016, 10(5): 2291-2296. doi: 10.12030/j.cjee.201504083
shu

曝气吹脱法用于牛场沼液污染物的去除

  • 1.

    西南大学资源环境学院, 重庆 400716

  • 2.

    西南大学重庆市农业资源与环境研究重点实验室, 重庆 400716

  • 基金项目:

    国家科技支撑计划项目(2010BAD03B03)

    重庆市环境保护科技项目(2013CF-301)

  • 中图分类号: X713

Pollutants removal characteristics by air stripping with aeration treating biogas slurry of cattle manure

  • 1.

    School of Resource and Environment, Southwest University, Chongqing 400716, China

  • 2.

    Chongqing Key Laboratory of Agricultural Resource and Environment, Southwest University, Chongqing 400716, China

  • Fund Project:

  • 摘要: 氨吹脱是一种有效的污水脱氮处理技术,其中曝气吹脱法又简单易行。为了探究曝气吹脱法用于牛场沼液污染物去除的最优条件,实验研究了温度、曝气量、初始pH等参数对氨氮去除效果的影响,并探讨了投加Ca(OH)2及曝气吹脱对COD、TP的去除作用。结果显示:温度、曝气量是影响氨氮去除效果的关键因素,30 ℃、4 000曝气量条件下氨氮去除率最高;由于沼液本身pH会受吹脱影响升高,因此,调节初始pH在8~9.5范围内对氨氮去除效果无显著影响;Ca(OH)2能去除少量COD及TP,吹脱也能对COD去除有一定影响,投加7.7 g/L Ca(OH)2吹脱后,沼液COD、TP去除率分别为9.7%、14.8%。最优条件30 ℃、4 000曝气量下,不加Ca(OH)2吹脱能得到70%以上的的氨氮去除率。一般情况下建议不加Ca(OH)2进行沼液氨吹脱。
    Abstract: Ammonia stripping is an effective technology used to remove nitrogen from sewage, including aeration, which is simple and feasible. In order to obtain the air stripping optimal conditions, the influences of temperature, aeration quantity and initial pH on ammonium (NH4+-N) removal efficiencies were investigated respectively, and the effects of Ca(OH)2 usage and aeration on chemical oxygen demand (COD) and total phosphrous (TP) removal were also studied.The results showed that the temperature and aeration were key factors, and the NH4+-N removal rate reached to the highest with 30 ℃ and 4 000. Because the pH of biogas slurry could increase with aeration, the effect of pH on NH4+-N removal was insignificant with the initial pH of 8 to 9.5. Ca(OH)2 could be useful for removing COD and TP, and aeration was helpful to remove COD. The removal rates of COD and TP were 9.7% and 14.8% respectively, when the Ca(OH)2 usage was 7.7 g/L. The NH4+-N removal rate could be more than 70% with 30 ℃, aeration 4 000, and no Ca(OH)2 addition. Normally, aeration without alkaline agents was the suggested way to remove nitrogen in the ammonia stripping process.
  • 加载中
  • [1] 耿维, 胡林, 崔建宇, 等. 中国区域畜禽粪便能源潜力及总量控制研究. 农业工程学报, 2013, 29(1): 171-179 Geng Wei, Hu Lin, Cui Jianyu, et al. Biogas energy potential for livestock manure and gross control of animal feeding in region level of China. Transactions of the Chinese Society of Agricultural Engineering, 2013, 29(1): 171-179(in Chinese)
    [2] 王飞, 蔡亚庆, 仇焕广. 中国沼气发展的现状、驱动及制约因素分析. 农业工程学报, 2012, 28(1): 184-189 Wang Fei, Cai Yaqing, Qiu Huanguang. Current status, incentives and constraints for future development of biogas industry in China. Transactions of the CSAE, 2012, 28(1): 184-189(in Chinese)
    [3] Zhang Zhaoji, Li Yuanyuan, Chen Shaohua, et al. Simultaneous nitrogen and carbon removal from swine digester liquor by the Canon process and denitrification. Bioresource Technology, 2012, 114: 84-89
    [4] 邓良伟, 郑平, 李淑兰, 等. 添加原水改善SBR工艺处理猪场废水厌氧消化液性能. 环境科学, 2005, 26(6): 105-109 Deng Liangwei, Zheng Ping, Li Shulan, et al. Performance improvement of sequencing batch reactor (SBR) treating digested piggery wastewater by addition of raw wastewater. Environmental Science, 2005, 26(6): 105-109(in Chinese)
    [5] 姜维, 王小佳, 贾仁勇, 等. 吹脱法预处理皮革废水的实验研究. 环境工程学报, 2010, 4(4): 789-794 Jang Wei, Wang Xiaojia, Jia Renyong, et al. Experimental study on pretreatment of tannery wastewater by air stripping. Chinese Journal of Environmental Engineering, 2010, 4(4): 789-794(in Chinese)
    [6] 王辉. 吹脱-生化组合工艺处理尿素废水的技术研究. 哈尔滨: 哈尔滨工业大学硕士学位论文, 2006 Wang Hui. Research on treatment of urea wastewater via combined process of air stripping and biological technology. Harbin: Master Dissertation of Harbin Institute of Technology, 2006(in Chinese)
    [7] 金彪, 李广贺, 张旭. 吹脱技术净化石油污染地下水实验. 环境科学, 2000, 21(4): 102-105 Jin Biao, Li Guanghe, Zhang Xu. Air stripping technique of purifying groundwater polluted by petroleum hydrocarbon. Environmental Science, 2000, 21(4): 102-105(in Chinese)
    [8] 王文斌, 董有, 刘士庭. 吹脱法去除垃圾渗滤液中的氨氮研究. 环境污染治理技术与设备, 2004, 5(6): 51-53 Wang Wenbin, Dong You, Liu Shiting. Air stripping to remove ammonia nitrogen in landfill leachate. Techniques and Equipment for Environmental Pollution Control, 2004, 5(6): 51-53(in Chinese)
    [9] 樊希葆, 柯水洲, 欧阳衡. 吹脱法在去除垃圾填埋场渗滤液中的氨氮的应用. 中外建筑, 2005(5): 104-105 Fan Xibao, Ke Shuizhou, Ouyang Heng. The application of blowing & doffing method to remove the ammonia and nitrogen from the rubbish burying district filtrate. Chinese and Overseas Architecture, 2005(5): 104-105(in Chinese)
    [10] Bonmatí A., Flotats X. Air stripping of ammonia from pig slurry: Characterisation and feasibility as a pre- or post-treatment to mesophilic anaerobic digestion. Waste Management, 2003, 23(3): 261-272
    [11] 隋倩雯, 董红敏, 朱志平, 等. 提高猪场沼液净化处理效果的氨吹脱控制参数. 农业工程学报, 2012, 28(11): 205-211 Sui Qianwen, Dong Hongmin, Zhu Zhiping, et al. Ammonia stripping control parameters for improving effluent treatment effect in anaerobic digesters of piggery wastewater. Transactions of the Chinese Society of Agricultural Engineering, 2012, 28(11): 205-211(in Chinese)
    [12] 金要勇, 孟海玲, 刘再亮, 等. 奶牛养殖废水厌氧出水的吹脱混凝处理实验研究. 农业环境科学学报, 2015, 34(2): 384-390 Jin Yaoyong, Meng Hailing, Liu Zailiang, et al. Treatment of anaerobic effluent of dairy wastewater by ammonia stripping-coagulation combination. Journal of Agro-Environment Science, 2015, 34(2): 384-390(in Chinese)
    [13] Guštin S., Marinšek-Logar R. Effect of pH, temperature and air flow rate on the continuous ammonia stripping of the anaerobic digestion effluent. Process Safety and Environment Protection, 2011, 89(1): 61-66
    [14] Lei Zhang, Deokjin J. Enhanced anaerobic digestion of piggery wastewater by ammonia stripping: Effects of alkali types. Journal of Hazardous Materials, 2010, 182(1-3): 536-543
    [15] Lei Xiaohui, Sugiura N., Feng Chuanping, et al. Pretreatment of anaerobic digestion effluent with ammonia stripping and biogas purification. Journal of Hazardous Materials, 2007, 145(3): 391-397
    [16] Popovic O., Jensen L. S. Storage temperature affects distribution of carbon, VFA, ammonia, phosphorus, copper and zinc in raw pig slurry and its separated liquid fraction. Water Research, 2012, 46(12): 3849-3858
  • 加载中
WeChat 点击查看大图
计量
  • 文章访问数:  2396
  • HTML全文浏览数:  1939
  • PDF下载数:  925
  • 施引文献:  0
出版历程
  • 收稿日期:  2015-05-18
  • 刊出日期:  2016-06-03
龚川南, 陈玉成, 黄磊. 曝气吹脱法用于牛场沼液污染物的去除[J]. 环境工程学报, 2016, 10(5): 2291-2296. doi: 10.12030/j.cjee.201504083
引用本文: 龚川南, 陈玉成, 黄磊. 曝气吹脱法用于牛场沼液污染物的去除[J]. 环境工程学报, 2016, 10(5): 2291-2296. doi: 10.12030/j.cjee.201504083
shu
Gong Chuannan, Chen Yucheng, Huang Lei. Pollutants removal characteristics by air stripping with aeration treating biogas slurry of cattle manure[J]. Chinese Journal of Environmental Engineering, 2016, 10(5): 2291-2296. doi: 10.12030/j.cjee.201504083
Citation: Gong Chuannan, Chen Yucheng, Huang Lei. Pollutants removal characteristics by air stripping with aeration treating biogas slurry of cattle manure[J]. Chinese Journal of Environmental Engineering, 2016, 10(5): 2291-2296. doi: 10.12030/j.cjee.201504083
shu

曝气吹脱法用于牛场沼液污染物的去除

  • 1.  西南大学资源环境学院, 重庆 400716
  • 2.  西南大学重庆市农业资源与环境研究重点实验室, 重庆 400716
  • 收稿日期:  2015-05-18
基金项目:

国家科技支撑计划项目(2010BAD03B03)

重庆市环境保护科技项目(2013CF-301)

摘要: 氨吹脱是一种有效的污水脱氮处理技术,其中曝气吹脱法又简单易行。为了探究曝气吹脱法用于牛场沼液污染物去除的最优条件,实验研究了温度、曝气量、初始pH等参数对氨氮去除效果的影响,并探讨了投加Ca(OH)2及曝气吹脱对COD、TP的去除作用。结果显示:温度、曝气量是影响氨氮去除效果的关键因素,30 ℃、4 000曝气量条件下氨氮去除率最高;由于沼液本身pH会受吹脱影响升高,因此,调节初始pH在8~9.5范围内对氨氮去除效果无显著影响;Ca(OH)2能去除少量COD及TP,吹脱也能对COD去除有一定影响,投加7.7 g/L Ca(OH)2吹脱后,沼液COD、TP去除率分别为9.7%、14.8%。最优条件30 ℃、4 000曝气量下,不加Ca(OH)2吹脱能得到70%以上的的氨氮去除率。一般情况下建议不加Ca(OH)2进行沼液氨吹脱。

English Abstract

    全文HTML

参考文献 (16)

返回顶部

目录

/

返回文章
返回

Copyright © 2019 中国科学院生态环境研究中心