高级搜索

牛骨粉为晶种的磷酸钙结晶法回收污泥发酵液中磷

,  ,  , 

downloadPDF

上一篇

下一篇

谷彩霞, 张超杰, 李咏梅, 周琪. 牛骨粉为晶种的磷酸钙结晶法回收污泥发酵液中磷[J]. 环境工程学报, 2015, 9(7): 3127-3133. doi: 10.12030/j.cjee.20150709
引用本文: 谷彩霞, 张超杰, 李咏梅, 周琪. 牛骨粉为晶种的磷酸钙结晶法回收污泥发酵液中磷[J]. 环境工程学报, 2015, 9(7): 3127-3133. doi: 10.12030/j.cjee.20150709
shu
Gu Caixia, Zhang Chaojie, Li Yongmei, Zhou Qi. Phosphorus recovery from sludge fermentation broth by cow-bone powder-seeded crystallization of calcium phosphate[J]. Chinese Journal of Environmental Engineering, 2015, 9(7): 3127-3133. doi: 10.12030/j.cjee.20150709
Citation: Gu Caixia, Zhang Chaojie, Li Yongmei, Zhou Qi. Phosphorus recovery from sludge fermentation broth by cow-bone powder-seeded crystallization of calcium phosphate[J]. Chinese Journal of Environmental Engineering, 2015, 9(7): 3127-3133. doi: 10.12030/j.cjee.20150709
shu

牛骨粉为晶种的磷酸钙结晶法回收污泥发酵液中磷

  • 1.

    同济大学环境科学与工程学院, 上海 200092

  • 基金项目:

    国家"863"高技术研究发展计划项目子课题(2011AA-060902)

  • 中图分类号: X703

Phosphorus recovery from sludge fermentation broth by cow-bone powder-seeded crystallization of calcium phosphate

  • 1.

    College of Environmental Science & Engineering, Tongji University, Shanghai 200092, China

  • Fund Project:

  • 摘要: 以牛骨粉为晶种材料,研究不同的反应条件对磷酸钙结晶法回收污泥碱性发酵液中磷的影响。结果表明,最优反应条件为:搅拌时间2 h,pH=10.0,Ca/P摩尔比2.0,在此条件下,发酵液的浓度升高会降低磷的回收率,且成线性关系。运用扫描电子显微镜(SEM)、X-射线衍射仪(XRD)、EDX元素分析等测试方法分析晶体的组分,并与其他晶种的效果作对比,结果表明,以牛骨粉为晶种,产生的羟基磷酸钙晶体纯度更高。在实验得到的最优条件下进行流化床小试实验,可得以牛骨粉为晶种的磷酸钙结晶法磷的回收率可达89.8%,验证了以牛骨粉为晶种回收污泥发酵液中的磷在小试水平上的可行性。
    Abstract: Taking cow-bone powder as the seed crystal,the effects of the reaction conditions for the recovery of phosphorus from sludge fermentation broth using crystallization of calcium phosphate were investigated.Results indicated that reaction time of 2 h,pH value of 10.0,Ca/P molar ratio of 2 were the favorable conditions.Under the optimal reaction conditions,the recovery rate of phosphorus decreased linearly with the increase of fermentation broth concentration.Analytical techniques such as scanning electron microscopy (SEM),powder X-ray diffraction (XRD) and energy dispersive X-Ray spectroscopy (EDX) were used to analyze the components of the crystals,and the result showed that the HAP produced with cow-bone powder as the seed crystal were purer than those produced with seed crystals.The lab trials of fluidized bed were established to recycle phosphorus under the optimum reaction conditions,and the recovery rate of phosphorus reached 89.8% with cow-bone powder as the seed crystal,proving that it is feasible to recovery phosphorus from sludge fermentation broth with the seed crystal in pilot-scale.
  • 加载中
  • [1] Fischer F.,Bastian C.,Happe M.,et al.Microbial fuel cell enables phosphate recovery from digested sewage sludge as struvite.Bioresource Technology,2011,102(10):5824-5830
    [2] de-Bashan L.E.,Bashan Y.Recent advances in removing phosphorus from wastewater and its future use as fertilizer(1997—2003).Water Research,2004,38(19):4222-4246
    [3] Jang Hong,Kang S.H.Phosphorus removal using cow bone in hydroxyapatite crystallization.Water Research,2002,36(5):1324-1330
    [4] 佟娟.剩余污泥碱性发酵产生的短链脂肪酸作为生物脱氮除磷碳源的研究.上海:同济大学博士学位论文,2008 Tong Juan.Alkaline fermentative short-chain fatty acids produced from excess activated sludge as the carbon sources of biological nutrients removal.Shanghai:Doctor Dissertation of Tongji University,2008
    [5] 肖本益,刘俊新.污水处理系统剩余污泥碱处理融胞效果研究.环境科学,2006,27(2):319-323 Xiao Benyi,Liu Junxin.Study on treatment of excess sludge under alkaline condition.Environmental Science,2006,27(2):319-323(in Chinese)
    [6] 汪群慧.固体废物处理及资源化.北京:化学工业出版社,2004:227-231 Wang Qunhui.Solid waste treatment and resources.Beijing:Chemical Industry Press,2004:227-231(in Chinese)
    [7] 胡亚冰,张超杰,张辰,等.碱解处理对剩余污泥融胞效果及厌氧消化产气效果.四川环境,2009,28(1):1-4 Hu Yabing,Zhang Chaojie,Zhang Chen,et al.Effect of alkaline hydrolysis on excess sludge disintegration and gas production of anaerobic digestion.Sichuan Environment,2009,28(1):1-4(in Chinese)
    [8] 郑蕾,田禹,孙德智.pH值对活性污泥胞外聚合物分子结构和表面特征影响研究.环境科学,2007,28(7):1507-1511 Zheng Lei,Tian Yu,Sun Dezhi.Effects of pH on the surface characteristics and molecular structure of extracellular polymeric substances from activated sludge.Environmental Science,2007,28(7):1507-1511(in Chinese)
    [9] Becerra F.Y.G.,Acosta E.J.,Allen D.G.Alkaline extraction of wastewater activated sludge biosolids.Bioresource Technology,2010,101(18):6972-6980
    [10] Song Yonghui,Weidler P.G.,Berg U.,et al.Calcite-seeded crystallization of calcium phosphate for phosphorus recovery.Chemosphere,2006,63(2):236-243
    [11] 缪幸福.HAP法回收废水中磷的反应条件优化控制研究.芜湖:安徽工程大学硕士学位论文,2012 Miao Xingfu.The optimal control study of using hydroxyapatite (HAP) Method to recover phosphorus in wastewater in order to find the best optimum reaction conditions.Wuhu:Master Dissertation of Anhui Polytechnic University,2012
    [12] 段金明,张亚平,方宏达,等.转炉渣诱导磷酸钙结晶法去除和回收废水中磷的研究.环境工程学报,2010,4(7):1576-1580 Duan Jinming,Zhang Yaping,Fang Hongda,et al.Removal and recovery phosphorus from wastewater by converter slag-seeded crystallization of calcium phosphate.Chinese Journal of Environmental Engineering,2010,4(7):1576-1580(in Chinese)
    [13] 缪幸福,魏翔,徐建平,等.以羟基磷酸钙结晶方式回收废水中磷的试验研究.安徽工程大学学报,2012,27(2):36-39 Miao Xingfu,Wei Xiang,Xu Jianping,et al.On the crystallization of hydroxyl calcium phosphate to reclaim the phosphorus in waste water.Journal of Anhui Polytechnic University,2012,27(2):36-39(in Chinese)
    [14] 高英.环境中磷回收的磷酸盐矿物结晶热力学计算模拟.北京:中国地质大学硕士学位论文,2007 Gao Ying.Thermodynamic simulation of phosphate crystallization for phosphorus recovery in environment.Beijing:Master Dissertation of China University of Geosciences,2007
    [15] 朱建平.碱性发酵污泥有机物的分离及氮与磷的回收.哈尔滨:哈尔滨工业大学硕士学位论文,2013 Zhu Jianping.The organics separation and ammonia and phosphorus recovery of alkaline fermentation sludge.Harbin:Master Dissertation of Harbin Institute of Technology,2013
    [16] Freche M.,Rouquet N.,Koutsoukos P.G.,et al.Effect of humic compounds on the crystal growth of dicalcium phosphate dihydrate.Agrochimica,1992,36(6):500-510
    [17] 万锐,吕锡武,朱光灿,等.诱导结晶法回收磷的试验研究.中国给水排水,2009,25(15):82-85 Wan Rui,Lv Xiwu,Zhu Guangcan,et al.Study on phosphorus recovery by induced crystallization.China Water & Wastewater,2009,25(15):82-85(in Chinese)
    [18] 王海亭,陈磊,金雪玲,等.羟基磷灰石(HAP)材料在生物材料中的研究与开发.山东陶瓷,2002,25(2):3-8 Wang Haiting,Chen Lei,Jin Xueling,et al.The research and development of hydroxyapatite in the bioceramics.Shandong Ceramics,2002,25(2):3-8(in Chinese)
  • 加载中
WeChat 点击查看大图
计量
  • 文章访问数:  2347
  • HTML全文浏览数:  1708
  • PDF下载数:  591
  • 施引文献:  0
出版历程
  • 收稿日期:  2014-06-08
  • 刊出日期:  2015-07-02
谷彩霞, 张超杰, 李咏梅, 周琪. 牛骨粉为晶种的磷酸钙结晶法回收污泥发酵液中磷[J]. 环境工程学报, 2015, 9(7): 3127-3133. doi: 10.12030/j.cjee.20150709
引用本文: 谷彩霞, 张超杰, 李咏梅, 周琪. 牛骨粉为晶种的磷酸钙结晶法回收污泥发酵液中磷[J]. 环境工程学报, 2015, 9(7): 3127-3133. doi: 10.12030/j.cjee.20150709
shu
Gu Caixia, Zhang Chaojie, Li Yongmei, Zhou Qi. Phosphorus recovery from sludge fermentation broth by cow-bone powder-seeded crystallization of calcium phosphate[J]. Chinese Journal of Environmental Engineering, 2015, 9(7): 3127-3133. doi: 10.12030/j.cjee.20150709
Citation: Gu Caixia, Zhang Chaojie, Li Yongmei, Zhou Qi. Phosphorus recovery from sludge fermentation broth by cow-bone powder-seeded crystallization of calcium phosphate[J]. Chinese Journal of Environmental Engineering, 2015, 9(7): 3127-3133. doi: 10.12030/j.cjee.20150709
shu

牛骨粉为晶种的磷酸钙结晶法回收污泥发酵液中磷

  • 1. 同济大学环境科学与工程学院, 上海 200092
  • 收稿日期:  2014-06-08
基金项目:

国家"863"高技术研究发展计划项目子课题(2011AA-060902)

摘要: 以牛骨粉为晶种材料,研究不同的反应条件对磷酸钙结晶法回收污泥碱性发酵液中磷的影响。结果表明,最优反应条件为:搅拌时间2 h,pH=10.0,Ca/P摩尔比2.0,在此条件下,发酵液的浓度升高会降低磷的回收率,且成线性关系。运用扫描电子显微镜(SEM)、X-射线衍射仪(XRD)、EDX元素分析等测试方法分析晶体的组分,并与其他晶种的效果作对比,结果表明,以牛骨粉为晶种,产生的羟基磷酸钙晶体纯度更高。在实验得到的最优条件下进行流化床小试实验,可得以牛骨粉为晶种的磷酸钙结晶法磷的回收率可达89.8%,验证了以牛骨粉为晶种回收污泥发酵液中的磷在小试水平上的可行性。

English Abstract

    全文HTML

参考文献 (18)

返回顶部

目录

/

返回文章
返回

Copyright © 2019 中国科学院生态环境研究中心