高级搜索

颗粒活性炭催化臭氧氧化降解活性黑5

,  ,  , 

downloadPDF

上一篇

下一篇

刘莹, 吴德礼, 何宏平, 张亚雷. 颗粒活性炭催化臭氧氧化降解活性黑5[J]. 环境化学, 2016, 35(5): 990-997. doi: 10.7524/j.issn.0254-6108.2016.05.2016011001
引用本文: 刘莹, 吴德礼, 何宏平, 张亚雷. 颗粒活性炭催化臭氧氧化降解活性黑5[J]. 环境化学, 2016, 35(5): 990-997. doi: 10.7524/j.issn.0254-6108.2016.05.2016011001
shu
LIU Ying, WU Deli, HE Hongping, ZHANG Yalei. Catalytic ozonation of aqueous reactive black 5 with granular activated carbon[J]. Environmental Chemistry, 2016, 35(5): 990-997. doi: 10.7524/j.issn.0254-6108.2016.05.2016011001
Citation: LIU Ying, WU Deli, HE Hongping, ZHANG Yalei. Catalytic ozonation of aqueous reactive black 5 with granular activated carbon[J]. Environmental Chemistry, 2016, 35(5): 990-997. doi: 10.7524/j.issn.0254-6108.2016.05.2016011001
shu

颗粒活性炭催化臭氧氧化降解活性黑5

  • 1.

    同济大学环境科学与工程学院污染控制与资源化研究国家重点实验室, 上海, 200092

  • 基金项目:

    国家十二五科技支撑计划(2012BAJ25B04)资助.

Catalytic ozonation of aqueous reactive black 5 with granular activated carbon

  • 1.

    State Key Laboratory of Pollution Control and Resources Reuse, School of Environmental Science & Engineering, Tongji University, Shanghai, 200092, China

  • Fund Project: Supported by National Key Technology R&D Program(2012BAJ25B04).

  • 摘要: 本文以深度处理后印染废水为配水模拟实际废水,对颗粒活性炭催化臭氧氧化降解活性黑5进行了研究.用低温N2吸附-脱附等温线、SEM-EDS等对颗粒活性炭进行了表征,发现颗粒活性炭比表面积高达931 m2·g-1.考察了颗粒活性炭吸附性能和催化臭氧活性,结果表明单独臭氧与颗粒活性炭催化臭氧脱色率在反应30 min内均高达100%.反应1 h时,5 g·L-1、10 g·L-1颗粒活性炭催化臭氧TOC去除率分别为57%、74%,比单独臭氧高出33%和50%,颗粒活性炭具有良好的催化效果,能提高对污染物的矿化效果.颗粒活性炭促进了溶解性臭氧分解,重复使用6次后10 g·L-1活性炭在反应时间为2 h时染料废水TOC去除率均能稳定在85%左右,多次利用后活性炭的催化活性没有明显降低.EPR检测表明,其主要机制为颗粒活性炭能够稳定地催化臭氧分子分解产生羟基自由基,实现污水中有机物的矿化.
    Abstract: Catalytic ozonation of aqueous Reactive Black (RB5) in the presence of granular activated carbon (GAC) was investigated, employing the effluent from advanced treatment of dyeing wastewater as the simulated wastewater. The GAC was characterized by low temperature N2 adsorption-desorption isotherm and SEM-EDS. It was showed that the specific surface area of GAC reached 931 m2·g-1. In the experiments of GAC's adsorption performance and the catalytic activity of ozone, the results showed that the decolorization rate of GAC and ozone alone reached as high as 100% within 30 mins. While after one hour reaction, the TOC removal rate was 57% and 74% respectively in the presence of 5 g·L-1 and 10 g·L-1 GAC, which represented 33% and 50% increase compared to ozone alone. The GAC had good catalytic stability and enhanced the decomposition of the soluble ozone. 10 g·L-1 GAC showed a stable ability to treat the dyeing wastewater with the TOC removal rate as high as 85%, within 2 hours after 6 times reuse. EPR results manifested that the GAC steadily promoted the decomposition of ozone to generate hydroxyl radicals, which contributed significantly to the mineralization of the organic contaminants.
  • 加载中
  • [1] WU J N,WANG T W. Ozonation of aqueous azo dye in a semi-batch reactor[J]. Water Research,2001,35(4): 1093-1099.
    [2] STOLZ A. Basic and applied aspects in the microbial degradation of azo dyes[J]. Applied and Micrbiology Biotechnology,2001,56:69-80.
    [3] ALATON I A,BALCIOGLU I A,BAHNEMANN D W. Advanced oxidation of a reactive dye bath effuent: Comparison of O3,H2O2/UV-C and TiO2/UV-A processes[J]. Water Research,2002,36(5):1143-1154.
    [4] BRUNO L,DAVID A R,DEBORAH R B. Ozone in water treatment: Application and engineerig[M]. Lewis Publishers,Chelsea,MI,USA,1991.
    [5] LIU X Y,ZHOU Z M,JING G H,et al. Catalytic ozonation of Acid Red B in aqueous solution over a Fe-Cu-Ocatalyst[J]. Separation and Purification Technology,2013,115:129-135.
    [6] BARBARA K H,MARIA Z,JACEK N. Catalytic ozonation and methods of enhancing molecular ozone reactions in water treatment[J]. Applied Catalysis B: Environmental,2003,46(4):639-669.
    [7] RIVERA-UTRILLA J, SÁNCHEZ-POLO M. Ozonation of 1,3,6-naphthalenetrisulphonic acid catalysed by activated carbon in aqueous phase[J]. Applied Catalysis B: Environmental,2002,39(4):319-329.
    [8] BELTRAN F J,RIVAS F J,FERNANDEZ L A,et al. Kinetics of catalytic ozonation of oxalic acid in water with activated carbon[J]. Industrial & Engineering Chemistry Research,2005,41(25):6510-6517.
    [9] WANG D B,ZHANG Z Y,Li X M,et al. A full-scale treatment of freeway toll-gate domestic sewage using ecology filter integrated constructed rapid infiltration[J]. Ecological Engineering,2010,36(6):827-831.
    [10] 刘占孟,唐朝春,李静,等. 活性炭催化臭氧化降解亚甲基蓝试验[J].浙江林学院学报,2009,26(3):406-410.

    LIU Z M,TANG C C,LI J,et al. Catalytic ozonation with activated carbon for degreadation of methylene blue in wastewater[J]. Journal of Zhejiang Forestry College,2009,26(3):406-410(in Chinese).

    [11] FARIA P,ÓRFÃO J,PEREIRA M. Mineralisation of coloured aqueous solutions byozonation in the presence of activated carbon[J]. Water Research,2005,39(8):1461-1470.
    [12] 何宏平,吴德礼,吕亚平,等. 臭氧氧化四种偶氮染料废水的效果研究[J]. 环境科学与管理,2014,39(9):125-129.

    HE H P,WU D L,LYU Y P,et al. Study on removal of four azo dye wastewater by ozonation[J]. Environmental Science And Management,2014,39(9):125-129(in Chinese).

    [13] 钱飞跃,孙贤波,刘勇弟,等.活性炭-臭氧氧化法连续处理印染废水生化出水的性能[J].水处理技术,2014,40(2):92-101.

    QIAN F Y,SUN X B,LIU Y D,et al. Study on reclamation of biotreated textile wastewater by activatied carbon/ozone oxidation under continuous operation[J]. Technology of Wastewater Treatment,2014,40(2):92-101(in Chinese).

    [14] GEELHOED J S,HIEMSTRA T,VAN R W H. Phosphate and sulfate adsorption on goethite: Single anion and competitive adsorption[J]. Geochimica et CosmochimicaActa,1997,61(12):2389-2396.
    [15] ZHAO H,DONG Y,WANG G,et al. Novel magnetically separable nanomaterials for heterogeneous catalytic ozonation of phenol pollutant: NiFe2O4 and their performances[J]. Chemical Engineering Journal,2013,219:295-302.
    [16] BADER H,HOIGNÉ J. Determination of ozone in water by the indigo method[J]. Water Research,1981,15(4):449-456.
    [17] ZHAO L,MA J,SUN Z Z,et al. Catalytic ozonation for the degradation of nitrobenzene in aqueous solution by ceramic honeycomb-supported manganese[J]. Applied Catalysis B: Environmental,2008,83: 256-264
    [18] 万哲希,丁国际,余飞,等. 颗粒活性炭催化臭氧氧化降解焦化废水有机物[J]. 净水技术,2013,32(4): 61-66.

    WAN Z X,DING G J,YU F,et al. Catalytic ozonation with granular activated carbon (GAC) for degradation of organic matters in coking wastewater[J]. Technology of Wastewater Treatment,2013,32(4): 61-66(in Chinese).

    [19] JANS U,HOIGNÉ J. Activated carbon and carbon black catalyzed transformation of aqueous ozone into OH-radicals[J]. Ozone: Science and Engineering,1998,20(1-2):67-90.
    [20] FARIA P,ÓRFÃO J,PEREIRA M. Ozone decomposition in water catalyzed by activated carbon: influence of chemical and textural properties[J]. Industrial & Engineering Chemistry Research,2006,45(8): 2715-2721.
    [21] FARIA P,ÓRFÃO J,PEREIRA M. Ozonation of aniline promoted by activated carbon[J]. Chemosphere,2007,67(4):809-815.
    [22] FARIA P,ÓRFÃO JJM,PEREIRA M. Catalytic ozonation of sulfonated aromatic compounds in the presence of activated carbon[J].Applied Catalysis B: Environmental,2008,83(1-2):150-159.
    [23] PARK J S,CHOI H C,CHO J W. Kinetic decomposition of ozone and para-chlorobenzoic acid (pCBA) during catalytic Ozonation[J]. Water Research,2004,38(9):2285-2292.
    [24] STUMM W. Chemistry of the solid-water interface: Processes at the mineral-water and particle-water interface in natural systems[M]. New York: John Wiley and Sons,1992.
  • 加载中
WeChat 点击查看大图
计量
  • 文章访问数:  931
  • HTML全文浏览数:  865
  • PDF下载数:  545
  • 施引文献:  0
出版历程
  • 收稿日期:  2016-01-10
  • 刊出日期:  2016-05-15
刘莹, 吴德礼, 何宏平, 张亚雷. 颗粒活性炭催化臭氧氧化降解活性黑5[J]. 环境化学, 2016, 35(5): 990-997. doi: 10.7524/j.issn.0254-6108.2016.05.2016011001
引用本文: 刘莹, 吴德礼, 何宏平, 张亚雷. 颗粒活性炭催化臭氧氧化降解活性黑5[J]. 环境化学, 2016, 35(5): 990-997. doi: 10.7524/j.issn.0254-6108.2016.05.2016011001
shu
LIU Ying, WU Deli, HE Hongping, ZHANG Yalei. Catalytic ozonation of aqueous reactive black 5 with granular activated carbon[J]. Environmental Chemistry, 2016, 35(5): 990-997. doi: 10.7524/j.issn.0254-6108.2016.05.2016011001
Citation: LIU Ying, WU Deli, HE Hongping, ZHANG Yalei. Catalytic ozonation of aqueous reactive black 5 with granular activated carbon[J]. Environmental Chemistry, 2016, 35(5): 990-997. doi: 10.7524/j.issn.0254-6108.2016.05.2016011001
shu

颗粒活性炭催化臭氧氧化降解活性黑5

  • 1. 同济大学环境科学与工程学院污染控制与资源化研究国家重点实验室, 上海, 200092
  • 收稿日期:  2016-01-10
基金项目:

国家十二五科技支撑计划(2012BAJ25B04)资助.

摘要: 本文以深度处理后印染废水为配水模拟实际废水,对颗粒活性炭催化臭氧氧化降解活性黑5进行了研究.用低温N2吸附-脱附等温线、SEM-EDS等对颗粒活性炭进行了表征,发现颗粒活性炭比表面积高达931 m2·g-1.考察了颗粒活性炭吸附性能和催化臭氧活性,结果表明单独臭氧与颗粒活性炭催化臭氧脱色率在反应30 min内均高达100%.反应1 h时,5 g·L-1、10 g·L-1颗粒活性炭催化臭氧TOC去除率分别为57%、74%,比单独臭氧高出33%和50%,颗粒活性炭具有良好的催化效果,能提高对污染物的矿化效果.颗粒活性炭促进了溶解性臭氧分解,重复使用6次后10 g·L-1活性炭在反应时间为2 h时染料废水TOC去除率均能稳定在85%左右,多次利用后活性炭的催化活性没有明显降低.EPR检测表明,其主要机制为颗粒活性炭能够稳定地催化臭氧分子分解产生羟基自由基,实现污水中有机物的矿化.

English Abstract

    全文HTML

参考文献 (24)

返回顶部

目录

/

返回文章
返回

Copyright © 2019 中国科学院生态环境研究中心