高级搜索

VUV/O3降解选矿废水残留药剂实验探究

,  ,  ,  , 

downloadPDF

上一篇

下一篇

张大超, 吴梦, 陈敏, 邓晓裕, 王春英. VUV/O3降解选矿废水残留药剂实验探究[J]. 环境化学, 2019, (7): 1675-1681. doi: 10.7524/j.issn.0254-6108.2018091305
引用本文: 张大超, 吴梦, 陈敏, 邓晓裕, 王春英. VUV/O3降解选矿废水残留药剂实验探究[J]. 环境化学, 2019, (7): 1675-1681. doi: 10.7524/j.issn.0254-6108.2018091305
shu
ZHANG Dachao, WU Meng, CHEN Min, DENG Xiaoyu, WANG Chunying. Degradation of residual medicament of mineral processing wastewater by VUV/O3[J]. Environmental Chemistry, 2019, (7): 1675-1681. doi: 10.7524/j.issn.0254-6108.2018091305
Citation: ZHANG Dachao, WU Meng, CHEN Min, DENG Xiaoyu, WANG Chunying. Degradation of residual medicament of mineral processing wastewater by VUV/O3[J]. Environmental Chemistry, 2019, (7): 1675-1681. doi: 10.7524/j.issn.0254-6108.2018091305
shu

VUV/O3降解选矿废水残留药剂实验探究

  • 1. 江西理工大学资源与环境工程学院, 赣州, 341000;

  • 2. 江西省矿冶环境污染控制重点实验室, 赣州, 341000

    • 通讯作者: 张大超, E-mail: tel:13766377328 ; 
  • 基金项目:

    博士后科学基金（2015M582776XE，2016T90967）赞助.

Degradation of residual medicament of mineral processing wastewater by VUV/O3

  • 1. School of Resources and Environmental Engineering, Jiangxi University of Science and Technology, Ganzhou, 341000, China;

  • 2. Jiangxi Key Laboratory of Mining & Metallurgy Environmental Pollution Control, Ganzhou, 341000, China

    • Corresponding author: ZHANG Dachao, tel:13766377328 ; 
  • Fund Project: Supported by Postdoctoral Science Foundation Project(2015M582776XE,2016T90967).

  • 摘要: 以选矿废水残留药剂降解为研究目标，本文对VUV/O3（vacuum ultraviolet，VUV，真空紫外）降解松醇油进行了实验研究，考察了废水初始pH值、O3浓度、污染物初始浓度、反应时间、共存阴阳离子等因素对VUV/O3降解松醇油效果的影响，并得到最佳实验条件.实验表明，在VUV光源功率15 W、O3浓度为6 g·h-1、废水初始pH 8.0的条件下，VUV/O3对松醇油的降解效果最好，反应时间15 min，降解率就能达到99.99%；SiO32-、CO32-、Cl-、SO42-、Na+、Ca2+等6种共存离子对VUV/O3去除松醇油的效果均起抑制作用，其影响作用大小顺序为：CO32- > Ca2+ > SiO32- > SO42- > Cl-（Na+）.VUV/O3在降解松醇油的过程中，反应20 min后，溶液TOC的降解率达到平衡，为70.88%，而松醇油的降解率为99.14%；通过添加叔丁醇抑制剂对降解过程进行活性机理分析，认为·OH在VUV/O3降解松醇油过程中起主要作用.
    Abstract: In this paper, the degradation of pine oil by VUV/O3 (vacuum ultraviolet, VUV, vacuum ultraviolet) was studied. The influence of the initial pH value, O3 concentration, initial concentration of pollutants, reaction time and coexisting ions on VUV/O3 degradation of pine oil was investigated, and the optimum experimental conditions were obtained.The experiments showed that VUV/O3 has the best degradation effect on pine oil with the degradation rate of 99.99% under the conditions of VUV light source was 15W, O3 concentration was 6 g·h-1, initial pH 8, and the reaction time was 15 min. Six kinds of coexisting ions, such as SiO32-, CO32-, Cl-, SO42-, Na+ and Ca2+, inhibited the effect of VUV/O3 on the removal of pine oil. The order of effect was CO32- > Ca2+ > SiO32- > SO42- > Cl-(Na+). In the process of VUV/O3 degradation of pine oil, the degradation rate of TOC reached a balance of 70.88% in the solution and of the pine oil was 99.14% after the reaction time of 20 min. The activity mechanism of the degradation process was analyzed by adding t-BuOH inhibitors. It was considered that ·OH played a major role in the process of VUV/O3 degradation of pine oil.
  • 加载中
  • [1] 吴乔松,顾继东,王庆伟,等.多金属选矿废水深度处理与回用试验研究[J].广东化工,2016,43(8):115-117.

    WU Q S, GU J D, WANG Q W, et a1. Experimental study on deep treatment and reuse of polymetallic ore dressing wastewater[J]. Guangdong Chemical Industry, 2016, 43(8):115-117(in Chinese).

    [2] 白小霞,杨庆,丁昀,等.催化臭氧氧化处理难降解石化废水技术的研究进展[J].化工进展,2016,35(1):263-268.

    BAI X X, YANG Q, DING Y, et a1. Advances in catalytic ozonation for treatment of refractory petrochemical wastewater[J]. Chemical Industry and Engineering Progress, 2016, 35(1):263-268(in Chinese).

    [3] SONG S, HE Z Q, CHEN J M. US/O3 com-bination degradation of aniline in aqueous solution[J]. Ultra-sonics Sonochemistry, 2007,14(1):84-88.
    [4] 刘馥雯,郭琳,刘晨,等.选矿废水处理及回用技术进展[J].有色金属科学与工程,2017,8(1):134-138.

    LIU F W, GUO L, LIU C, et a1. Progress in treatment and reuse of mineral processing wastewater[J]. Nonferrous metal science and engineering, 2017, 8(1):134-138(in Chinese).

    [5] 王自超,刘兴宇,宋永胜.臭氧生物活性炭工艺处理某多金属硫化矿浮选废水的小试研究[J].环境工程学报,2013,5(1):1723-1728.

    WANG Z C, LIU X Y, SONG Y S. Experimental study on treatment of flotation wastewater from polymetallic sulfide ore by ozone bioactive carbon process[J]. Chinese Journal of Environmental Engineering, 2013, 5(1):1723-1728(in Chinese).

    [6] 孙怡,于利亮,黄浩斌,等.高级氧化技术处理难降解有机废水的研发趋势及实用化进展[J].化工学报,2017,68(5):1743-1756.

    SUN Y, YU L L, HUANG H B, et a1. Research and development trend and application progress of advanced oxidation technology for treatment of refractory organic wastewaters[J]. Journal of Chemical Industry, 2017, 68(5):1743-1756(in Chinese).

    [7] EVGENIA I, MIKA S. The use of low-cost adsorbents for wastewater purification in mining industries[J]. Environmental Science and Pollution Research, 201320(11):7878-7899.
    [8]
    [9] 梁杰慧,孙水裕,杜青平,等.松醇油降解菌的分离鉴定及降解条件优化[J].中国有色金属学报,2012, 22(11):3278-3284.

    LIANG J H, SUN S Y, DU Q P, et a1. Separation, identification and optimization of degradation conditions of terpinol oil degradation bacteria[J]. Chinese Journal of Nonferrous Metals, 2012, 22(11):3278-3284(in Chinese).

    [10] DONG Y B, LIN H, LIU Q L, et a1. Treatment of flotation wastewater using biological activated carbon[J]. Journal of Central South University, 2014, 21(9):3580-3587.
    [11] CHEN C, CHEN H, GUO X, et al. Advanced ozone treatment of heavy oil refining wastewater by activated carbon supported iron oxide[J]. Journal of Industrial & Engineering Chemistry, 2014, 20(5):2782-2791.
    [12] 张小娟,孙水裕,杜青平,等.含松醇油实际选矿废水的COD生物降解[J].环境工程学报,2013,7(11):4241-4245.

    ZHANG X J, SUN S Y, DU Q P, et al. COD biodegradation of practical mineral processing wastewater containing terpinol oil[J]. Chinese Journal of Environmental Engineering, 2013, 7(11):4241-4245(in Chinese).

    [13] FENG D, DEVENTER J S J V, ALDRICH C. Removal of pollutants from acid mine wastewater using metallurgical by-product slags[J]. Separation & Purification Technology, 2004, 40(1):61-67.
    [14] 杜青平,卢仁钵,郑志成,等. 4株优势菌联合挂膜对松醇油废水的治理[J].环境工程学报,2016,10(7):3396-3400.

    DU Q P, LU R B, ZHENG Z C, et al.Treatment of pine oil wastewater with joint biofilm of four predominant strains[J]. Chinese Journal of Environmental Engineering, 2016, 10(7):3396-3400(in Chinese).

    [15] 欧阳魁.臭氧法处理硫化矿选矿废水的新工艺及其机理研究[D].长沙:中南大学,2009. OU Y K. Study on the new process and mechanism of ozone treatment of sulfide ore dressing wastewater[D]. Changsha:Central South University, 2009(in Chinese).
    [16]
    [17] CHEN Q Q, WU P X, LI Y Y, et al. Heterogeneous photo·Fenton photo degradation of reactive brilliant orange X-GN over iron-pillared mont m orillonite under visible irradiation[J]. Journal of Hazardous Materials. 2009, 168(2/3):901-908.
    [18] 王兵,张悦,任宏洋,等.Mn3O4催化臭氧化钻井废水的作用机理[J].环境工程学报,2015,9(10):4811-4816.

    WANG B, ZHANG Y, REN H Y, et al. The action mechanism of Mn3O4 catalytic ozonated drilling wastewater[J]. Chinese Journal of Environmental Engineering, 2015, 9(10):4811-4816(in Chinese).

    [19] 张大超,陈敏,代振鹏,吴速英,王春英.真空紫外/空气氧化降解苯甲羟肟酸模拟废水[J].化工进展,2017,36(7):2639-2645.

    ZHANG D C, CHEN M, DAI Z P, et al. The simulated wastewater was degraded by vacuum ultraviolet/air oxidationr[J]. Chemical Industry and Engineering Progress, 2017, 36(7):2639-2645(in Chinese).

    [20] 李学艳,高乃云,沈吉敏,等.O3/H2O2降解水中致嗅物质2-MIB的效能与机理[J].环境科学学报,2009,29(2):344-352.

    LI X Y, GAO N Y, SHEN J M, et al. Efficiency and mechanism of O3/H2O2 degradation of 2-mib in water[J]. Journal of Environmental Sciences, 2009, 29(2):344-352(in Chinese).

  • 加载中
WeChat 点击查看大图
计量
  • 文章访问数:  1083
  • HTML全文浏览数:  1083
  • PDF下载数:  32
  • 施引文献:  0
出版历程
  • 收稿日期:  2018-09-13
张大超, 吴梦, 陈敏, 邓晓裕, 王春英. VUV/O3降解选矿废水残留药剂实验探究[J]. 环境化学, 2019, (7): 1675-1681. doi: 10.7524/j.issn.0254-6108.2018091305
引用本文: 张大超, 吴梦, 陈敏, 邓晓裕, 王春英. VUV/O3降解选矿废水残留药剂实验探究[J]. 环境化学, 2019, (7): 1675-1681. doi: 10.7524/j.issn.0254-6108.2018091305
shu
ZHANG Dachao, WU Meng, CHEN Min, DENG Xiaoyu, WANG Chunying. Degradation of residual medicament of mineral processing wastewater by VUV/O3[J]. Environmental Chemistry, 2019, (7): 1675-1681. doi: 10.7524/j.issn.0254-6108.2018091305
Citation: ZHANG Dachao, WU Meng, CHEN Min, DENG Xiaoyu, WANG Chunying. Degradation of residual medicament of mineral processing wastewater by VUV/O3[J]. Environmental Chemistry, 2019, (7): 1675-1681. doi: 10.7524/j.issn.0254-6108.2018091305
shu

VUV/O3降解选矿废水残留药剂实验探究

    通讯作者: 张大超, E-mail: tel:13766377328 ; 
  • 1. 江西理工大学资源与环境工程学院, 赣州, 341000;
  • 2. 江西省矿冶环境污染控制重点实验室, 赣州, 341000
  • 收稿日期:  2018-09-13
基金项目:

博士后科学基金（2015M582776XE，2016T90967）赞助.

摘要: 以选矿废水残留药剂降解为研究目标，本文对VUV/O3（vacuum ultraviolet，VUV，真空紫外）降解松醇油进行了实验研究，考察了废水初始pH值、O3浓度、污染物初始浓度、反应时间、共存阴阳离子等因素对VUV/O3降解松醇油效果的影响，并得到最佳实验条件.实验表明，在VUV光源功率15 W、O3浓度为6 g·h-1、废水初始pH 8.0的条件下，VUV/O3对松醇油的降解效果最好，反应时间15 min，降解率就能达到99.99%；SiO32-、CO32-、Cl-、SO42-、Na+、Ca2+等6种共存离子对VUV/O3去除松醇油的效果均起抑制作用，其影响作用大小顺序为：CO32- > Ca2+ > SiO32- > SO42- > Cl-（Na+）.VUV/O3在降解松醇油的过程中，反应20 min后，溶液TOC的降解率达到平衡，为70.88%，而松醇油的降解率为99.14%；通过添加叔丁醇抑制剂对降解过程进行活性机理分析，认为·OH在VUV/O3降解松醇油过程中起主要作用.

English Abstract

    全文HTML

参考文献 (20)

返回顶部

目录

/

返回文章
返回

Copyright © 2019 中国科学院生态环境研究中心