高级搜索

低温热氧化法强化剩余污泥微生物燃料电池的产电特性

,  ,  ,  ,  ,  ,  ,  ,  ,  , 

downloadPDF

上一篇

下一篇

郭珊, 阳柳, 龚育诚, 邢成广, 黄世豪, 王丹阳, 苗珂, 杨志舒, 刘志华, 赵文玉, 陈启杰. 低温热氧化法强化剩余污泥微生物燃料电池的产电特性[J]. 环境化学, 2020, (5): 1330-1336. doi: 10.7524/j.issn.0254-6108.2019081001
引用本文: 郭珊, 阳柳, 龚育诚, 邢成广, 黄世豪, 王丹阳, 苗珂, 杨志舒, 刘志华, 赵文玉, 陈启杰. 低温热氧化法强化剩余污泥微生物燃料电池的产电特性[J]. 环境化学, 2020, (5): 1330-1336. doi: 10.7524/j.issn.0254-6108.2019081001
shu
GUO Shan, YANG Liu, GONG Yucheng, XING Chengguang, HUANG Shihao, WANG Danyang, MIAO Ke, YANG Zhishu, LIU Zhihua, ZHAO Wenyu, CHEN Qijie. Power generation characteristics of sludge microbial fuel cell using low temperature thermal oxidation[J]. Environmental Chemistry, 2020, (5): 1330-1336. doi: 10.7524/j.issn.0254-6108.2019081001
Citation: GUO Shan, YANG Liu, GONG Yucheng, XING Chengguang, HUANG Shihao, WANG Danyang, MIAO Ke, YANG Zhishu, LIU Zhihua, ZHAO Wenyu, CHEN Qijie. Power generation characteristics of sludge microbial fuel cell using low temperature thermal oxidation[J]. Environmental Chemistry, 2020, (5): 1330-1336. doi: 10.7524/j.issn.0254-6108.2019081001
shu

低温热氧化法强化剩余污泥微生物燃料电池的产电特性

  • 长沙理工大学, 化学与食品工程学院, 电力与交通材料保护湖南省重点实验室, 长沙, 410004

    • 通讯作者: 刘志华, E-mail: lzhwcp@126.com ; 
  • 基金项目:

    长沙理工大学电力与交通材料保护湖南省重点实验室开放基金（2017CL09），2018年度湖南省重点研发计划项目（2018SK2011），长沙理工大学青年教师成长计划项目（2019QJCZ038）和湖南省教育厅优秀青年项目（19B040）资助.

Power generation characteristics of sludge microbial fuel cell using low temperature thermal oxidation

  • Hunan Provincial Key Laboratory of Materials Protection for Electric Power and Transportation, School of Chemistry and Food Engineering, Changsha University of Science and Technology, Changsha, 410004, China

    • Corresponding author: LIU Zhihua, lzhwcp@126.com ; 
  • Fund Project: Supported by the Hunan Provincial Key Laboratory of Materials Protection for Electric Power and Transportation (2017CL09), 2018 Key Research and Development Project of Hunan Province (2018SK2011), Youth Teacher Growth Plan Project of Changsha University of Science and Technology (2019QJCZ038) and Outstanding Youth Project of Hunan Provincial Department of Education (19B040).

  • 摘要: 城市污水处理厂污泥因有机物含量高而成为微生物燃料电池（MFC）应用研究的主要方向之一，而污泥中有机质的释放成为限制其发展的主要因素.本实验利用低温热解和过氧化氢氧化处理的耦合方法预处理城市污水处理厂污泥，分析了其作为燃料对MFC产电性能的影响.研究表明，利用预处理后的污泥上清液作为燃料，预处理温度、时间、pH值和过氧化氢投加量对MFC的产电性能影响大.当温度、时间、pH值和过氧化氢分别为100℃、90 min、11和500 g·kg TSS-1的预处理条件下，MFC功率密度最大，分别为235、287、233.2、280 mW·m-3.采用热氧化法预处理污泥，可有利于污泥的破解，使能被产电菌利用的营养物质增多，提高了MFC产电特性，可为污泥资源化利用提供有益的参考.
    Abstract: Sludge in municipal sewage treatment plants has become one of the main research directions of microbial fuel cell (MFC) application,due to its high organic content. However, the release of organic matter in sludge is the main factor of restricting its development. In this paper, the sludge in municipal sewage treatment plants was pretreated by the coupling method of low-temperature pyrolysis and hydrogen peroxide treatment, and the influence of it as fuel on the electrical performance of MFC was analyzed. The result showed that pretreatment temperature, time, pH value and hydrogen peroxide dosage had a great impact on the electricity generation of MFC when the pretreated sludge supernatant was used as fuel.When the pretreatment temperature, time, pH value and hydrogen peroxide were 100 ℃, 90 min, 11 and 500 g·kg tss-1 respectively, MFC Power Density reached the maximum value, which was 235, 287, 233.2, 280 mW·m-3.The pretreament of thermal oxidation was helpful for the solution of sludge, which increased the number of nutrients used by electricbacteria and improved the electricity generation characteristics of MFC. It could provide a beneficial reference for the utilization of sludge resources.
  • 加载中
  • [1] LOGAN B E, HAMELERS B, ROZENDAL R,et al. Microbial fuel cell:Methodology and technology[J]. Environmental Science and Technology,2006,40(17):5181-5192.
    [2] 韩天雪. 国内外污泥处理处置技术回顾与展望[J]. 环境与发展, 2018, 30(2):92-93.

    HAN T X. Review and prospect of sludge treatment and diposal at home and abroad[J]. Environment and Development, 2018, 30(2):92-93(in Chinese).

    [3] 戴晓虎. 我国城镇污泥处理处置现状及思考[J]. 给水排水, 2012, 38(2):1-5.

    DAIi X H. Current situation and consideration of urban sludge treatment in China[J]. Water and Wastewater Engineering, 2012, 38(2):1-5(in Chinese).

    [4] 卢年春,李萍,凌云,等. 城市污泥综合利用研究[J]. 安徽农业科学, 2005, 33:2101-2103. LU N C, LI P, LING Y,et al. Study on the utilization of municipal sewage sludge[J]. Journal of Anhui Agriclutural.Sciences, 2005

    , 33:2101-2103(in Chinese).

    [5] SCOTT K, MURANO C. A study of a microbial fuel cell battery using manure sludge waste[J].Journal of Chemical Technology and Biotechnology,2007,82(9):809-817.
    [6] LIU Z H, LI X M, JIA B,et al. Production of electricity from surplus sludge using a single chamber floating-cathode microbial fuel cell[J]. Water Science and Technology, 2009,60(9), 2399-2404.
    [7] OK J,PARK D, JUNG J W,et al. Feasibility study on electricity production from a sewage sludge extract using microbial fuel cell[J]. Journal of Nanoelectronics and Optoelectronics,2010,5(2):227-231.
    [8] JIANG J Q,ZHAO Q L,ZHANG J N,et al. Electricity generation from bio-treatment of sewage sludge with microbial fuel cell[J]. Bioresource Technology,2009,100(23):5808-5812.
    [9] JIANG J Q,ZHAO Q L,WEI L L,et al, Extracellular biological organic matters in microbial fuel cell using sewage sludge as fuel[J].Water Research, 2010,44(7):2163-2170.
    [10] JIANG J Q, ZHAO Q L,WANG K,et al. Effect of ultrasonic and alkaline pretreatment on sludge degradation and electricity generation by microbial fuel cell[J].Water Science and Technology,2010, 61(11):2915-2921.
    [11] XIAO B Y,YANG F, LIU J X. Evaluation of electricity production from alkaline pretreated sludge using two-chamber microbial fuel cell[J].Journal of Hazardous Materials,2013,254:57-63.
    [12] 蒋杭城,许蕾,谢静,等.超声预处理对剩余污泥微生物燃料电池性能的影响[J].环境化学,2015,34(5):989-994.

    JIANG H C,XU L,XIE J,et al. The effect of ultrasonic pretreated excess sludge on the performance of microbial fuel cells[J].Environmental Chemistry,2015,34(5):989-994(in Chinese).

    [13] 方丽,刘志华,李小明,等. 微波预处理污泥上清液为燃料的微生物燃料电池产电特性研究[J].环境科学,2010,31(10):2518-2524.

    FANG L,LIU Z H,LI X M,et al. Electricity generation by the microbial fuel cells using the supernatant fluid of microwave pretreated sludge as fuel[J].Environmental Science, 2010,31(10):2518-2524(in Chinese).

    [14] MOHD Z, HU A, FENG C J,et al. Influence of pretreated activated sludge for electricity generation in microbial fuel cell application[J]. Bioresource Technology, 2013,145:90-96.
    [15] 杨慧,刘志华,李小明,等. 外加酶强化剩余污泥微生物燃料电池产电特性的研究[J]. 环境科学,2012,33(1):216-221.

    YANG H,LIU Z H,LI X M,et al. Electricity generation of surplus sludge microbial fuel cells enhanced by additional enzyme[J].Environmental Science, 2012,33(1):216-221(in Chinese).

    [16] 刘志华,李小明,杨慧,等.不同方式处理污泥为燃料的微生物燃料电池特性研究[J].中国环境科学,2012,32(3):523-528.

    LIU Z H,LI X M,YANG H,et al. Microbial fuel cell using surplus sludge treated by different ways[J]. China Environmental Science, 2012,32(3):523-528(in Chinese).

    [17] 梁鹏,郭超,黄霞. 污泥水解液基质微生物燃料电池的研究[J].电化学,2013,19(4):332-335.

    LIANG P, GUO C, HUANG X. Using hydrolyzed sludge liquor as the substrate of microbial fuel cell[J]. Journal of Electrochemistry,2013,19(4):332-335(in Chinese).

    [18] 国家环保局编.水和废水监测分析方法第四版[M].北京:中国环境科学出版社,2002:102-209. State Environmental Protection Bureau. Methods for monitoring and analyzing water and wastewater, 4th edition[M]. Beijing:China Environmental Science Press,2002

    :102-209(in Chinese).

    [19] LOWRY O H, ROSEBROUGH N J, FARR A L, et al. Protein measurement with the folin phenol reagent[J]. J Biol Chem, 1951,193(1):265-275.
    [20] HERBERT D, PHILIPPS P J, STRANGE R E. Carbohydrate analysis[J]. Methods Enzymol B, 1971,5:265-277.
    [21] 刘志华,李小明,方丽,等.污泥为燃料的微生物燃料电池运行特性研究[J].中国环境科学,2012,32(2):268-273.

    LIU Z H,LI X M,FANG L,et al. Operating characteristic of microbial fuel cell using sludge[J]. China Environmental Science,2012,32(2):268-273(in Chinese).

    [22] LAURENT J, CASELLAS M, CARRERE H. Effects of thermal hydrolysis on activated sludge solubilization[J]. Surface Properties and Heavy Metals Biosorption,2010, 166(3):841-849.
    [23] 王治军,王伟,夏州,等. 热水解污泥的厌氧消化试验研究[J]. 中国给水排水, 2003,19(9):1-4.

    WANG Z J,WANG W,XIA Z,et al. Experimental study on thermal hydrolysis and anaerobic digestion of sewage sludge[J]. China Water and Wastewater, 2003,19(9):1-4(in Chinese).

    [24] 曹秀芹,柳婷,江坤,等. 低温热水解对污泥触变性及脱水性能的影响[J].环境工程学报,2019,13(4):977-983.

    CAO X Q,LIU T,JIANG K, et al. Effect of low-temperature thermal hydrolysis on sludge thixotropy and dewaterability[J]. Chinese Journal of Environmental Engineering, 2019,13(4):977-983(in Chinese).

    [25] CAMACHO P, DELERIS S. A comparative study between mechanical, thermal and oxidative disintegration techniques of waste activated sludge[J]. Wat Sci Tech, 2002, 46(10):79-87.
    [26] 宋天顺,吴夏芫,范平,等.以加热预处理污泥上清液为底物的微生物燃料电池基础研究特性[J].过程工程学报,2012,12(5):844-848.

    SONG T S,WU X Y,FAN P,et al.Basic electricity-producing characteristics of microbial fuel cell using supernatant fluid of heat pretreated sludge[J].The Chinese Journal of Process Engineering, 2012,12(5):844-848(in Chinese).

    [27] 潘碌亭,谢欣珏,万锕俊,等. 城市污水厂污泥碱性热水解的分离特性[J].环境工程,2018,36(2):120-124.

    PAN L T,XIE X Y,WANG A J,et al. Separation characteristics in alkaline thermal hydrolysis of sludge from municipal wastewater treatment plant[J]. Environmental Engineering, 2018,36(2):120-124(in Chinese).

    [28] 贾瑞来,魏源送,刘吉宝. 基于微波-过氧化氢-碱预处理的污泥水解影响因素[J].环境科学,2015,36(6):2222-2230.

    JIA R L,WEI Y S,LIU J B. Influencing factors for hydrolysis of sewage sludge pretreated by microwave-H2O2 -alkaline process[J].Environmental Science, 2015,36(6):2222-2230(in Chinese).

    [29] 柯水洲,李群一. 厌氧消化结合双氧水溶胞处理剩余污泥试验研究[J].环境工程,2016,34(7):134-139.

    KE S Z,LI Q Y. Treatment of excess activated sludge by combined anaerobic digestion and hydrogen peroxidelysis[J]. Environmental Engineering, 2016,7:134-139(in Chinese).

    [30] 马欣,邵艳珊,王来福,等. 双氧水对剩余污泥蛋白质释放过程研究[J]. 天津理工大学学报, 2016, 32(5):52-54

    ,59. MA X,SHAO Y S, WANG L F,et al. Research on the releasing extracellular polymeric substances process from sludge by hydrogen peroxide[J]. Journal of Tianjian University of Technology, 2016, 32(5):52-54,59(in Chinese).

    [31] DEWIL R, APPELS L, BAEYENS J, et al. Peroxidation enhances the biogas production in the anaerobic digestion of biosolids[J]. Journal of Hazardous Materials, 2007, 146(3):577-581.
  • 加载中
WeChat 点击查看大图
计量
  • 文章访问数:  2497
  • HTML全文浏览数:  2497
  • PDF下载数:  34
  • 施引文献:  0
出版历程
  • 收稿日期:  2019-08-10
郭珊, 阳柳, 龚育诚, 邢成广, 黄世豪, 王丹阳, 苗珂, 杨志舒, 刘志华, 赵文玉, 陈启杰. 低温热氧化法强化剩余污泥微生物燃料电池的产电特性[J]. 环境化学, 2020, (5): 1330-1336. doi: 10.7524/j.issn.0254-6108.2019081001
引用本文: 郭珊, 阳柳, 龚育诚, 邢成广, 黄世豪, 王丹阳, 苗珂, 杨志舒, 刘志华, 赵文玉, 陈启杰. 低温热氧化法强化剩余污泥微生物燃料电池的产电特性[J]. 环境化学, 2020, (5): 1330-1336. doi: 10.7524/j.issn.0254-6108.2019081001
shu
GUO Shan, YANG Liu, GONG Yucheng, XING Chengguang, HUANG Shihao, WANG Danyang, MIAO Ke, YANG Zhishu, LIU Zhihua, ZHAO Wenyu, CHEN Qijie. Power generation characteristics of sludge microbial fuel cell using low temperature thermal oxidation[J]. Environmental Chemistry, 2020, (5): 1330-1336. doi: 10.7524/j.issn.0254-6108.2019081001
Citation: GUO Shan, YANG Liu, GONG Yucheng, XING Chengguang, HUANG Shihao, WANG Danyang, MIAO Ke, YANG Zhishu, LIU Zhihua, ZHAO Wenyu, CHEN Qijie. Power generation characteristics of sludge microbial fuel cell using low temperature thermal oxidation[J]. Environmental Chemistry, 2020, (5): 1330-1336. doi: 10.7524/j.issn.0254-6108.2019081001
shu

低温热氧化法强化剩余污泥微生物燃料电池的产电特性

    通讯作者: 刘志华, E-mail: lzhwcp@126.com ; 
  • 长沙理工大学, 化学与食品工程学院, 电力与交通材料保护湖南省重点实验室, 长沙, 410004
  • 收稿日期:  2019-08-10
基金项目:

长沙理工大学电力与交通材料保护湖南省重点实验室开放基金（2017CL09），2018年度湖南省重点研发计划项目（2018SK2011），长沙理工大学青年教师成长计划项目（2019QJCZ038）和湖南省教育厅优秀青年项目（19B040）资助.

摘要: 城市污水处理厂污泥因有机物含量高而成为微生物燃料电池（MFC）应用研究的主要方向之一，而污泥中有机质的释放成为限制其发展的主要因素.本实验利用低温热解和过氧化氢氧化处理的耦合方法预处理城市污水处理厂污泥，分析了其作为燃料对MFC产电性能的影响.研究表明，利用预处理后的污泥上清液作为燃料，预处理温度、时间、pH值和过氧化氢投加量对MFC的产电性能影响大.当温度、时间、pH值和过氧化氢分别为100℃、90 min、11和500 g·kg TSS-1的预处理条件下，MFC功率密度最大，分别为235、287、233.2、280 mW·m-3.采用热氧化法预处理污泥，可有利于污泥的破解，使能被产电菌利用的营养物质增多，提高了MFC产电特性，可为污泥资源化利用提供有益的参考.

English Abstract

    全文HTML

参考文献 (31)

返回顶部

目录

/

返回文章
返回

Copyright © 2019 中国科学院生态环境研究中心