高级搜索

废旧线路板中贵金属湿法浸出技术研究进展

,  ,  ,  , 

downloadPDF

上一篇

下一篇

王志辉, 苑舒琪, 刘景昊, 吴玉锋, 俞嘉梅. 废旧线路板中贵金属湿法浸出技术研究进展[J]. 环境化学, 2021, (3): 886-895. doi: 10.7524/j.issn.0254-6108.2020070701
引用本文: 王志辉, 苑舒琪, 刘景昊, 吴玉锋, 俞嘉梅. 废旧线路板中贵金属湿法浸出技术研究进展[J]. 环境化学, 2021, (3): 886-895. doi: 10.7524/j.issn.0254-6108.2020070701
shu
WANG Zhihui, YUAN Shuqi, LIU Jinghao, WU Yufeng, YU Jiamei. Research progress of hydrometallurgy technology for leaching precious metals in waste printed circuit board[J]. Environmental Chemistry, 2021, (3): 886-895. doi: 10.7524/j.issn.0254-6108.2020070701
Citation: WANG Zhihui, YUAN Shuqi, LIU Jinghao, WU Yufeng, YU Jiamei. Research progress of hydrometallurgy technology for leaching precious metals in waste printed circuit board[J]. Environmental Chemistry, 2021, (3): 886-895. doi: 10.7524/j.issn.0254-6108.2020070701
shu

废旧线路板中贵金属湿法浸出技术研究进展

  • 北京工业大学材料科学与工程学院, 北京, 100124

    • 通讯作者: 俞嘉梅, E-mail: jyu@bjut.edu.cn
  • 基金项目:

    国家重点研发计划课题（2018YFC1902506）资助.

Research progress of hydrometallurgy technology for leaching precious metals in waste printed circuit board

  • Materials Science and Engineering College of Beijing University of Technology, Beijing, 100124, China

    • Corresponding author: YU Jiamei, jyu@bjut.edu.cn
  • Fund Project: Supported by National Key Research and Development Program (2018YFC1902506).

  • 摘要: 废旧线路板（WPCB）的数量逐年增长，妥善处理废旧线路板不仅体现其回收利用价值，并且具有可观的环境效益.湿法处理废旧线路板工艺成熟，具有流程短、效率高的优点.本文综述了废旧线路板中贵金属（主要以金为例）浸出方法的研究状况，并从效率、环境影响、成本等方面对不同方法进行了比较.分析表明，硫脲法和碘化法浸出效率高、环境影响小、成本可控，是较优的浸出方法.合理、有效地处置废旧线路板，减少处置过程中的环境污染并高效回收贵金属，需要考虑不同方面的因素，多种浸出与富集回收方法共同使用，以达到最佳贵金属回收效果.
    Abstract: The number of waste printed circuit boards (WPCB) is increasing year by year, and proper disposal of waste printed circuit boards not only reflects its recycling value, but also has considerable environmental benefits. Hydrometallurgy processing of WPCB technology is mature, with the advantages of short process, high efficiency.This article summarized the leading-edge reports of leaching methods of precious metals(mainly taking Au as an example) in WPCB,and compared these methods from the aspects of efficiency, environmental impact, and cost evaluation.The analysis showed that thiourea method and the iodization method were the best leaching methods with high leaching efficiency, low environmental impact and controllable cost.It was proposed that reasonable and effective disposal of WPCB, reduction environmental pollution in the process of disposal and efficient recovery of precious metals. It is necessary to consider different factors and use different leaching and enrichment recovery methods together to achieve the best recovery effect of precious metals.
  • 加载中
  • [1] XU C, ZHANG W, HE W, et al. The situation of waste mobile phone management in developed countries and development status in China[J]. Waste Management,2016, 58:341-347.
    [2] 2019全国报废手机预计达到4.99亿部废旧手机存量累积就约18.3亿台[EB/OL].[2019-12-29]. http://it.chinairn.com/news/20191229/141814557.html 2019 National discarded mobile phones is expected to reach 499 million old stock accumulation is about 1.83 billion[EB/OL].[2019-12-29]. http://it.chinairn.com/news/20191229/141814557.html(in Chinese).
    [3] HE W Z, LI G M, MA X F. WEEE recovery strate-gies and the WEEE treatment status in China[J]. Journal of Hazardous Materials, 2006, 136(3):502-512.
    [4] 最"环保冶奥运奖牌亮相东京奥运会倒计时一周年庆典[EB/OL].[2019-07-25].http://japan.people.com.cn/n1/2019/0725/c35421-31256556.html The most environmentally friendly Olympic medal has been unveiled at the one-year countdown to the Tokyo Olympics[EB/OL].[2019-07-25].http://japan.people.com.cn/n1/2019/0725/c35421-31256556.html
    [5] 陈静静,李彬,戴煜,等. 废线路板回收技术的现状分析[J]. 现代化工,2019,39(5):42-48.

    CHEN J J, LI B, DAI Y, et al. Status Analysis of waste circuit board recovery technology[J]. Modern Chemical Industry,2019,39(5):42-48(in Chinese).

    [6] MELCHIORRE M,JAKOB R.Electronic scrap recycling[J]. Mi-croelectronics Journal,1997,28:22-24.
    [7] 肖力,王永良,钱鹏,等. 非氰提金技术研究进展[J]. 黄金科学技术,2019,27(2):292-301.

    XIAO L, WANG Y L, QIAN P, et al. Research progress of non-cyanogenic gold extraction technology[J]. Gold Science and Technology, 2019, 27(2):292-301(in Chinese).

    [8] 白建峰,白静,王鹏程,等. 酸性硫脲浸出废旧手机线路板中金的研究[J]. 矿冶工程. 2015,35(2):87-90.

    BAI J F, BAI J, WANG P C, et al. Study on gold in acid thiourea leaching of waste mobile phone circuit board[J]. Mining and Metallurgical Engineering, 2015,35(2):87-90(in Chinese).

    [9] 黄祥浩,柯昌美,杨金堂,等. 硫脲法浸出废弃电脑线路板中金的研究[J].无机盐工业,2019,6(51):62-64.

    HUANG X H, KE C M, YANG J T, et al. Gold leaching of waste computer circuit board by thiourea method[J]. Inorganic Salt Industry,2019,6(51):62-64(in Chinese).

    [10] LI J Y, XU X L,LIU W Q.Thiourea leaching gold and silver from the printed circuit boards of waste mobile phones[J]. Waste Management,2012(32):1209-1212.
    [11] BIRLOAGA I, VEGLIÒ F.Study of multi-step hydrometallurgical methods to extract the valuable content of gold, silver and copper from waste printed circuit boards[J]. Journal of Environmental Chemical Engineering,2016,4(1):20-29.
    [12] GURUNG M, ADHIKARI B B, KAWAKITA H, et al. Recovery of gold and silver from spent mobile phones by means of acidothiourea leaching followed by adsorption using biosorbent prepared from persimmon tannin[J].Hydrometallurgy, 2013, 133:84-93.
    [13] HAO J J,WANG Y S,WU Y F, et al. Metal recovery from waste printed circuit boards:A review for current status and perspectives[J]. Resources, Conservation and Recycling,2020,157:104787.
    [14] RIZKI I N, TANAKA Y, OKIBE N. Thiourea bioleaching for gold recycling from e-waste[J].Waste Management,2019,84:158-165.
    [15] GUO X Y, ZHANG L, TIAN Q, et al. Stepwise extraction of gold and silver from refractory gold concentrate calcine by thiourea[J]. Hydrometallurgy,2020, 194:105330.
    [16] 张晓飞,柴立元,王云燕. 硫脲浸金新进展[J]. 湖南冶金,2003,31(6):3-7.

    ZHANG X F, CHAI L Y, WANG Y Y. Progress of thiourea leaching[J]. Hunan Metallurgy,2003,31(6):3-7(in Chinese).

    [17] CRISTIAN V,PATRICIO N,DANIEL E, et al. Dissolution behavior of gold in alkaline media using thiourea[J]. International Journal of Nonferrous Metallurgy,2019,8(1):1-8.
    [18] CHAI L Y,MASAZUMI O.Dissolution theory of gold in alkaline thiourea solution(Ⅰ):Anodic behavior on gold in alkaline thiourea solution containing Na2SO3[J]. Transaction of Nonferrous Metals Society of China,1999, 9(1):145-151.
    [19] 朱忠泗. 硫脲类非氰化浸金药剂的制备及应用研究[D]. 长沙:中南大学,2014. ZHU Z S. Preparation and application of thiourea gold leaching agents[D].Changsha:Central South University, 2014(in Chinese).
    [20] 赵鹤飞,杨洪英,张勤,等. 硫代硫酸盐浸金各因素影响研究现状[J]. 黄金科学与技术,2018,26(1):105-114.

    ZHAO H F, YANG H Y, ZHANG Q, et al. Research status of various factors influencing thiosulphate leaching[J]. Gold Science and Technology, 2018, 26(1):105-114(in Chinese).

    [21] 姜涛,许时,陈荩.硫代硫酸盐浸金电化学研究:(Ⅱ)阴极行为及浸金机理[J]. 中南大学学报(自然科学版),1993,24(2):174-180. JIANG T, XU S, CHEN J. Thiosulfate leaching gold electrochemical research:(Ⅱ) cathode behavior and mechanism of gold leaching[J]. Journal of Central South University:(Natural Science Edition), 1993, 24(2):174-180(in Chinese).
    [22] CAMELINO S,RAO J,PADILLA R L,et al.Initial studies aboutgold leaching from printed circuit boards (PCB's) of waste cell phones[J]. Procedia Materials Science,2015,9:105-112.
    [23] 韩彬,童雄,谢贤,等. 硫代硫酸盐浸金体系研究进展[J]. 矿产综合利用,2015(3):11-16. HAN B, TONG X, XIE X, et al. Research progress of thiosulfate leaching system[J]. Mineral Comprehensive Utilization,2015

    (3):11-16(in Chinese).

    [24] GÁMEZ S, GARCÉS K, DE LA TORRE E, et al. Precious metals recovery from waste printed circuit boards using thiosulfate leaching and ion exchange resin Hydrometallurgy,2019,168:1-11.
    [25] 吴阳红. 硫代硫酸盐法提取银[J]. 有色矿冶,2000,16(5):28-30.

    WU Y H. Extraction of silver by thiosulfate[J]. Nonferrous metallurgy, 2000,16(5):28-30(in Chinese).

    [26] NIE Y, YANG L, WANG Q, et al.Connection between gold dissolution in thiosulfate leaching and Cu(Ⅱ) complexes during the cathodic process[J]. Electrochimica Acta,2019,328:135079.
    [27] 朱亚茹,张小平,丁江玲,等. 硫代硫酸盐法浸取废旧手机元器件中的银[J].环境工程,2017,35(2):111-116.

    ZHU Y R, ZHANG X P, DING J L, et al. Extraction of silver from waste mobile phone components by thiosulfate method[J]. Environmental Engineering, 2017, 35(2):111-116(in Chinese).

    [28] 项朋志,刘龙江,黄遥,等.硫代硫酸盐-EDTA-铜离子体系浸金工艺研究[J].稀有金属,2019,44(5):1-7.

    XIANG P Z, LIU L J, HUANG Y, et al. Study on leaching process of thiosulphate-EDta-Copper ion system[J]. Rare Metals,2019, 44(5):1-7(in Chinese).

    [29] PUENTE-SILLER D M, FUENTES-ACEITUNO J C, NAVA-ALONSO F. Study of thiosulfate leaching of silver sulfide in the presence of EDTA and sodium citrate. Effect of NaOH and NH4OH[J]. Hydrometallurgy, 2014, 149:1-11.
    [30] 徐秀丽. 从电子废弃物中浸金的实验方法研究[D].青岛:青岛科技大学, 2011. XU X L. Experimental method research on gold leaching from e-waste[D]. Qingdao:Qingdao University of Science and Technology, 2011(in Chinese).
    [31] 钟俊. 非氰浸金技术的研究及应用现状[J]. 黄金科学技术,2011,19(6):57-61.

    ZHONG J. Research and Application status of non-cyanide leaching technology[J]. Gold Science and Technology, 2011, 19(6):57-61(in Chinese).

    [32] BEHNAMFARD A, SALARIRAD M, VEGLIO F. Process development for recovery of copper and precious metals from waste printed circuit boards with emphasize on palladium and gold leaching and precipitation[J].Waste Management,2013,33(11):2354-2363.
    [33] LU Y, SONG Q, XU Z. Integrated technology for recovering Au from waste memory module by chlorination process:Selective leaching, extraction, and distillation[J]. Journal of Cleaner Production, 2017, 161:30-39.
    [34] DING Y, ZHANG S, LIU B, et al. Integrated process for recycling copper anode slime from electronic waste smelting[J]. Journal of Cleaner Production, 2017, 165:48-56.
    [35] 吕进云,李桂春. 几种典型的非氰提金法研究进展[J]. 现代矿业,2009,25(8):11-13.

    LYU J Y, LI G C. Research progress of several typical non-cyanogenic gold extraction methods[J]. Modern Mining, 2009, 25(8):11-13(in Chinese).

    [36] 胡杨甲,贺政,赵志强,等.非氰浸金技术发展现状及应用前景[J].黄金,2018,39(4):53-58.

    HU Y J, HE Z, ZHAO Z Q, et al. Development status and Application prospect of non-cyanide leaching technology[J]. Gold,2018, 39(4):53-58(in Chinese).

    [37] 李宗站. 难浸金精矿常温常压强碱预处理及溴化浸出试验研究[D]. 淄博:山东理工大学,2011. LI Z Z.Experimental study on alkali pretreatment and bromination leaching of refractory gold concentrate at normal temperature and pressure[D]. Zibo:Shandong University of Technology, 2011(in Chinese).
    [38] 刘建华,陈赛军.溴化法浸取硫化矿中的金[J].化工时刊,2003,17(4):38-39.

    LIU J H, CHEN S J. Extraction of gold from sulfide ores by bromination[J]. Journal of Chemical Industry,2003,17(4):38-39(in Chinese).

    [39] YOSHIMURA A, TAKAI M, MATSUNO Y. Novel process for recycling gold from secondary sources:Leaching of gold by dimethyl sulfoxide solutions containing copper bromide and precipitation with water[J]. Hydrometallurgy,2014, 149:177-182.
    [40] SOUSA R, FUTURO A, FIÚZA A, et al. Bromine leaching as an alternative method for gold dissolution[J]. Minerals Engineering,2018, 118:16-23.
    [41] 张潇尹,陈亮,方宗堂. 非氰试剂从废印刷线路板中浸金进展[J].有色金属,2009, 61(1):72-76.

    ZHANG X Y, CHEN L, FANG Z T. Progress of gold leaching from waste printed circuit boards with non-cyanogen reagents[J]. Nonferrous Metals, 2009, 61(1):72-76(in Chinese).

    [42] DAVIS A.Solution chemistry of iodide leaching of gold[J].Hydrometallurgy,1993, 32(2):143-159.
    [43] SAHIN M, AKCIL A, ERUST C,et al. A potential alternative for precious metal recovery from E-waste:Lodine leaching[J]. Separation Science and Technology,2015,50:2587-2595.
    [44] ALTANSUKH B, HAGA K, ARIUNBOLOR N, et al. Leaching and adsorption of gold from waste printed circuit boards using iodine-iodide solution and activated carbon[J]. Engineering Journal,2016, 20(4):29-40.
    [45] XU Q, CHEN D H, CHEN L, et al. Gold leaching from waste printed circuit board by iodine process[J]. Nonferrous Metals, 2010, 62:88-90.
    [46] XIU F, QI Y, ZHANG F. Leaching of Au, Ag, and Pd from waste printed circuit boards of mobile phone by iodide lixiviant after supercritical water pre-treatment[J]. Waste Management, 2015, 41:134-141.
    [47] ISLAM A, AHMED T, AWUAL M R, et al. Advances in sustainable approaches to recover metals from e-waste-A review[J]. Journal of Cleaner Production,2020, 244:118815.
    [48] MARRA A, CESARO A, RENE E R, et al. Bioleaching of metals from WEEE shredding dust[J]. Journal of Environmental Management,2018, 210:180-190.
    [49] NATARAJAN G, TING Y. Gold biorecovery from e-waste:An improved strategy through spent medium leaching with pH modification[J]. Chemosphere,2015, 136:232-238.
    [50] KUMAR A,SAIN H.S I,KUMAR S.Bioleaching of gold and silver from waste printed circuit boards by pseudomonas balearica SAE1 isolated from an e-waste recycling facility[J]. Current Microbiology, 2018, 75(2):194-201.
    [51] ARSHADI M, MOUSAVI S M. Enhancement of simultaneous gold and copper extraction from computer printed circuit boards using Bacillus megaterium[J]. Bioresource Technology, 2015, 175:315-324.
    [52] 傅开彬,陈海焱,谌书,等.微生物在废弃印刷线路板资源化中的应用研究进展[J].金属矿山,2016(1):176-181. FU K B, CHEN H Y, CHEN S, et al. Application research progress of microorganism in recycling of waste printed circuit board[J]. Metal Mine,2016

    (1):176-181(in Chinese).

    [53] LI H, EKSTEEN J, ORABY E. Hydrometallurgical recovery of metals from waste printed circuit boards (WPCBs):Current status and perspectives-A review[J]. Resources, Conservation and Recycling, 2018, 139:122-139.
    [54] ORABY E A, EKSTEEN J J.E, TANDA B C. Gold and copper leaching from gold-copper ores and concentrates using a synergistic lixiviant mixture of glycine and cyanide[J]. Hydrometallurgy,2017, 169:339-345.
    [55] ORABY E A, EKSTEEN J J. The leaching of gold, silver and their alloys in alkaline glycine-peroxide solutions and their adsorption on carbon[J]. Hydrometallurgy, 2015, 152:199-203.
    [56] ORABY E A, EKSTEEN J J. Gold leaching in cyanide-starved copper solutions in the presence of glycine[J]. Hydrometallurgy,2015, 156:81-88.
    [57] PEREA C G, RESTREPO O J. Use of amino acids for gold dissolution[J]. Hydrometallurgy, 2018, 177:79-85.
    [58] 刘倩,白建峰,顾卫华,等.废弃印刷线路板资源化中的微生物[J].上海第二工业大学学报,2018,35(3):197-202.

    LIU Q, BAI J F, GU W H, et al. Microbe in recycling waste printed circuit boards[J]. Journal of Shanghai Second University of Technology, 2018, 35(3):197-202(in Chinese).

    [59] PANT D, JOSHI D, UPRETI M K, et al. Chemical and biological extraction of metals present in E waste:A hybrid technology[J]. Waste Management, 2012, 32(5):979-990.
    [60] PANT D, SINGH P, UPRETI M K. Metal leaching from cathode ray tube waste using combination of Serratia plymuthica and EDTA[J]. Hydrometallurgy, 2014, 146:89-95.
    [61] AWASTHI A K, LI J. An overview of the potential of eco-friendly hybrid strategy for metal recycling from WEEE[J]. Resources, Conservation and Recycling, 2017, 126:228-239.
    [62] ZHANG Y, LIU S, XIE H, et al. Current status on leaching precious metals from waste printed circuit boards[J]. Procedia Environmental Sciences,2012, 16:560-568.
  • 加载中
WeChat 点击查看大图
计量
  • 文章访问数:  2547
  • HTML全文浏览数:  2547
  • PDF下载数:  70
  • 施引文献:  0
出版历程
  • 收稿日期:  2020-07-06

废旧线路板中贵金属湿法浸出技术研究进展

    通讯作者: 俞嘉梅, E-mail: jyu@bjut.edu.cn
  • 北京工业大学材料科学与工程学院, 北京, 100124
  • 收稿日期:  2020-07-06
基金项目:

国家重点研发计划课题（2018YFC1902506）资助.

摘要: 废旧线路板（WPCB）的数量逐年增长，妥善处理废旧线路板不仅体现其回收利用价值，并且具有可观的环境效益.湿法处理废旧线路板工艺成熟，具有流程短、效率高的优点.本文综述了废旧线路板中贵金属（主要以金为例）浸出方法的研究状况，并从效率、环境影响、成本等方面对不同方法进行了比较.分析表明，硫脲法和碘化法浸出效率高、环境影响小、成本可控，是较优的浸出方法.合理、有效地处置废旧线路板，减少处置过程中的环境污染并高效回收贵金属，需要考虑不同方面的因素，多种浸出与富集回收方法共同使用，以达到最佳贵金属回收效果.

English Abstract

    全文HTML

参考文献 (62)

目录

/

返回文章
返回

Copyright © 2019 中国科学院生态环境研究中心