高级搜索

多通道网状电极电化学预处理垃圾渗滤液反渗透浓缩液

,  ,  ,  , 

downloadPDF

上一篇

下一篇

晏超群, 程治良, 全学军, 封承飞, 程赓. 多通道网状电极电化学预处理垃圾渗滤液反渗透浓缩液[J]. 环境化学, 2021, (2): 603-613. doi: 10.7524/j.issn.0254-6108.2020030801
引用本文: 晏超群, 程治良, 全学军, 封承飞, 程赓. 多通道网状电极电化学预处理垃圾渗滤液反渗透浓缩液[J]. 环境化学, 2021, (2): 603-613. doi: 10.7524/j.issn.0254-6108.2020030801
shu
YAN Chaoqun, CHENG Zhiliang, QUAN Xuejun, FENG Chengfei, CHENG Geng. Electrochemical pretreatment of landfill leachate RO concentrate with multi-channel mesh electrodes[J]. Environmental Chemistry, 2021, (2): 603-613. doi: 10.7524/j.issn.0254-6108.2020030801
Citation: YAN Chaoqun, CHENG Zhiliang, QUAN Xuejun, FENG Chengfei, CHENG Geng. Electrochemical pretreatment of landfill leachate RO concentrate with multi-channel mesh electrodes[J]. Environmental Chemistry, 2021, (2): 603-613. doi: 10.7524/j.issn.0254-6108.2020030801
shu

多通道网状电极电化学预处理垃圾渗滤液反渗透浓缩液

  • 重庆市化工废水处理与污染控制工程技术研究中心, 重庆理工大学化学化工学院, 重庆, 400054

    • 通讯作者: 程治良, E-mail: purper@cqut.edu.cn ; 
  • 基金项目:

    重庆市生活垃圾资源化处理协同创新中心项目（Shljzyh2017-003）和重庆市基础与前沿研究计划（ｃｓｔｃ2015ｊｃｙｊA20005，cstc2020jcyjmsxmX0308）资助.

Electrochemical pretreatment of landfill leachate RO concentrate with multi-channel mesh electrodes

  • Chongqing Technology Research Center of Chemical Engineering Wastewater Treatment and Pollution Control, School of Chemistry and Chemical Engineering, Chongqing University of Technology, Chongqing, 400054, China

    • Corresponding author: CHENG Zhiliang, purper@cqut.edu.cn ; 
  • Fund Project: Supported by the Research Funds of Chongqing Collaborative Innovation Center Of Municipal Solid Waste Treatment and Resources Recovery (Shljzyh2017-003) and the Foundation and Frontier Research Project of Chongqing (cstc2015jcyjA20005,cstc2020jcyjmsxmX0308).

  • 摘要: 反渗透（Reverse Osmosis，RO）因出水水质好、运行成本低等优势常用于垃圾渗滤液的处理，但产生的RO浓缩液具有COD高、色度高、盐分高、难降解等特点，其处理存在效果差、能耗和成本均较高等问题.本工作采用氧化钌/氧化铱涂层电极（RuO2/IrO2-Ti）的钛网为阳极，以304不锈钢电极为阴极，设计制作了6通道的电化学反应器，通过电化学氧化处理RO浓缩液，研究考查了电流密度、循环流速、比电极面积等参数对COD去除效果的影响，分析了电化学氧化去除难降解有机物并同时脱盐的过程机理与能耗.结果表明，在电流密度32.89 mA·cm-2，循环流速0.46 cm·s-1，比电极面积65.10 m2·m-3的条件下，电化学氧化处理RO浓缩液3 h，COD去除率可达68.0%，TOC去除率可达40.6%，脱盐率可达72.1%，去除单位质量COD能耗仅为常规的板状电极电化学反应器的25.5%.本工作可为垃圾渗滤液RO浓缩液的预处理提供新思路.
    Abstract: Reverse osmosis (RO) is widely used in the treatment of the municipal solid waste leachate because it has the advantage of high quality of treated effluent, low running cost, etc. However, the concentrate produced during the RO process has high COD, high color, high salt content and is extremely hard to be degraded. At present, the treatment of RO concentrate is rather costly, low efficient and high energy consumption. In order to solve these problems, a novel electrochemical treatment process of RO concentrate in a homemade six-channel electrochemical reactor with the RuO2/IrO2 coated titanium mesh anodes and the 304 stainless steel plate cathodes were proposed. The effect of operation parameters of the current density, liquid circulation velocity and specific electrode area on COD removal was investigated. The degradation mechanism of the refractory organics and the energy consumption of the electrochemical oxidation process were also analyzed and calculated. The results show the COD, TOC and salt removal efficiency was 68.0%, 40.6% and 72.1% respectively after electrochemical treatment for 3 hours under the optimal conditions of current density of 32.89 mA·cm-2, liquid circulation velocity of 0.46 cm·s-1, and the specific electrode area of 65.1 m2·m-3. Compared with the conventional electrochemical treatment process using plate electrodes, the per kilogram COD removal energy consumption of the proposed electrochemical process is only 25.5% of the former one. Therefore, this work could provide an alternative choice for the pretreatment of landfill leachate RO concentrate.
  • 加载中
  • [1] LUO H, ZENG Y, CHENG Y, et al. Recent advances in municipal landfill leachate:A review focusing on its characteristics, treatment, and toxicity assessment[J]. Science of The Total Environment, 2020, 703:135468.
    [2] REN X, SONG K, XIAO Y, et al. Effective treatment of spacer tube reverse osmosis membrane concentrated leachate from an incineration power plant using coagulation coupled with electrochemical treatment processes[J]. Chemosphere, 2020, 244:125479.
    [3] 王云海, 张瑞娜, 楼紫阳, 等. Fenton氧化处理垃圾膜滤浓缩液[J]. 环境化学, 2017, 36(5):1104-1111.

    WANG Y H, ZHANG R N, LOU Z Y, et al. Fenton oxidation process of concentrated landfill leachate[J]. Environmental Chemistry, 2017, 36(5):1104-1111(in Chinese).

    [4] SHI J, DANG Y, QU D, et al. Effective treatment of reverse osmosis concentrate from incineration leachate using direct contact membrane distillation coupled with a NaOH·PAM pre-treatment process[J]. Chemosphere, 2019, 220:195-203.
    [5] FERNADES A, LABIADH L, CIRIACO L, et al. Electro-Fenton oxidation of reverse osmosis concentrate from sanitary landfill leachate:Evaluation of operational parameters[J]. Chemosphere, 2017, 184:1223-1229.
    [6] ZHAO J, OUYANG F, YANG Y, et al. Degradation of recalcitrant organics in nanofiltration concentrate from biologically pretreated landfill leachate by ultraviolet-Fenton method[J]. Separation and Purification Technology, 2020, 235:116076.
    [7] WANG H, WANG Y, LI X, et al. Removal of humic substances from reverse osmosis (RO) and nanofiltration (NF) concentrated leachate using continuously ozone generation-reaction treatment equipment[J]. Waste Management, 2016, 56:271-279.
    [8] LABIADH L, FERNANDES A, CIRIACO L, et al. Electrochemical treatment of concentrate from reverse osmosis of sanitary landfill leachate[J]. Journal of Environmental Management, 2016, 181:515-521.
    [9] GUWENC S. Optimization of COD removal from leachate nanofiltration concentrate using H2O2/Fe2+ heat-Activated persulfate oxidation processes[J]. Process Safety and Environmental Protection, 2019, 126:7-17.
    [10] CHEN W, GU Z, WEN P, et al. Degradation of refractory organic contaminants in membrane concentrates from landfill leachate by a combined coagulation-ozonation process[J]. Chemosphere, 2019, 217:411-422.
    [11] QIN H, CHEN H. Pretreatment of concentrated leachate by the combination of coagulation and catalytic ozonation with Ce/AC catalyst[J]. Water Science & Technology, 2016, 73(3):511-519.
    [12] ZHOU B, YU Z, WEI Q, et al. Electrochemical oxidation of biological pretreated and membrane separated landfill leachate concentrates on boron doped diamond anode[J]. Applied Surface Science, 2016, 377:406-415.
    [13] LAZHAR L, ANNABEL F, LURDES C, et al. Electrochemical treatment of concentrate from reverse osmosis of sanitary landfill leachate[J]. Journal of Environmental Management, 2016, 181:515-521.
    [14] QUAN X, CHENG Z, CHEN B, et al. Electrochemical oxidation of recalcitrant organic compounds in biologically treated municipal solid waste leachate in a flow reactor[J]. Journal of Environmental Sciences, 2013, 25(10):2023-2030.
    [15] 邓阳, 冯传平, 胡伟武, 等. 垃圾渗滤液生化出水电化学处理技术[J]. 环境化学, 2018, 37(5):1128-1140.

    DENG Y, FENG C P, HU W W, et al. Electrochemical degradation of biologically treated landfill leachate[J]. Environmental Chemistry, 2018, 37(5):1128-1140(in Chinese).

    [16] 国家环境保护局. 水和废水监测分析方法(第四版,增补版)[M]. 北京:中国环境科学出版社, 2011. State Environmental Protection Administration. Water and wastewater monitoring and analysis methods (Fourth Edition, supplement)[M]. Beijing:China Environmental Science Press, 2011(in Chinese).
    [17] 晏云鹏, 全学军, 葛淑萍, 等. 垃圾渗滤液生化出水絮凝纳滤处理及过程机理[J]. 化工学报, 2015, 66(6):2280-2287.

    YAN Y P, QUAN X J, GE S P, et al. Flocculation-nanofiltration treatment of biologically treated leachate and process mechanism[J]. Journal of Chemical Industry and Engineering, 2015, 66(6):2280-2287(in Chinese).

    [18] 晏云鹏, 全学军, 程治良, 等. 垃圾焚烧发电厂渗滤液生化出水的催化臭氧氧化处理[J]. 环境工程学报, 2015, 9(1):219-224.

    YAN Y P, QUAN X J, CHENG Z L, et al. Catalytic ozonation of biologically treated leachate from municipal solid waste incineration power plant[J]. Chinese Journal of Environmental Engineering, 2015, 9(1):219-224(in Chinese).

    [19] 谭怀琴, 全学军, 陈波, 等. 电化学处理改善垃圾沥滤液生化出水的微滤性能[J]. 工业水处理, 2013, 33(12):21-24.

    TAN H Q, QUAN X J, CHEN B, et al. Enhancement of micro-filtration capacity for biochemically treated effluent from garbage leachate by electrochemical oxidation process[J]. Industrial Water Treatment, 2013, 33(12):21-24(in Chinese).

    [20] YANG K S, MUL G, MOULIJN J A. Electrochemical generation of hydrogen peroxide using surface area-enhanced Ti-mesh electrodes[J]. Electrochimica Acta, 2007, 52(22):6304-6309.
    [21] KIM J, SONG S. A study on landfill leachate treatment with electrolysis[J]. Journal of the Korean Industrial and Engineering Chemistry, 2001, 12(4):439-443.
    [22] CHIANG L, CHANG J, WEN T. Indirect oxidation effect in electrochemical oxidation treatment of landfill leachate[J]. Water Research, 1995, 29(2):671-678.
    [23] 黄利, 万玉山, 蔡强, 等. 电化学氧化组合工艺处理垃圾渗滤液[J]. 环境工程学报, 2016, 10(2):593-598.

    HUANG L, WAN Y S, CAI Q, et al. Treatment of landfill leachate with electrochemical oxidation combined process[J]. Chinese Journal of Environmental Engineering, 2016, 10(2):593-598(in Chinese).

    [24] DENG Y, ENGLEHARDT J. Electrochemical oxidation for landfill leachate treatment[J]. Waste Management. 2007, 27(3):380-388.
    [25] 夏鹏飞, 魏晓云, 刘锐平, 等. 强化混凝-光电氧化组合技术深度处理垃圾渗滤液[J]. 环境科学学报, 2011, 31(1):13-19.

    XIA P F, WEI X Y, LIU R P, et al. Treatment of landfill leachate by an enhanced coagulation and photoelectro-oxidation process[J]. Acta Scientiae Circumstantiae, 2011, 31(1):13-19(in Chinese).

    [26] RAJESHWAR K, IBANEZ J, SWAIN G. Electrochemistry and the environment[J]. Journal of Applied Electrochemistry, 1994, 24(11):1077-1091.
  • 加载中
WeChat 点击查看大图
计量
  • 文章访问数:  2058
  • HTML全文浏览数:  2058
  • PDF下载数:  45
  • 施引文献:  0
出版历程
  • 收稿日期:  2020-03-08

多通道网状电极电化学预处理垃圾渗滤液反渗透浓缩液

    通讯作者: 程治良, E-mail: purper@cqut.edu.cn ; 
  • 重庆市化工废水处理与污染控制工程技术研究中心, 重庆理工大学化学化工学院, 重庆, 400054
  • 收稿日期:  2020-03-08
基金项目:

重庆市生活垃圾资源化处理协同创新中心项目（Shljzyh2017-003）和重庆市基础与前沿研究计划（ｃｓｔｃ2015ｊｃｙｊA20005，cstc2020jcyjmsxmX0308）资助.

摘要: 反渗透（Reverse Osmosis，RO）因出水水质好、运行成本低等优势常用于垃圾渗滤液的处理，但产生的RO浓缩液具有COD高、色度高、盐分高、难降解等特点，其处理存在效果差、能耗和成本均较高等问题.本工作采用氧化钌/氧化铱涂层电极（RuO2/IrO2-Ti）的钛网为阳极，以304不锈钢电极为阴极，设计制作了6通道的电化学反应器，通过电化学氧化处理RO浓缩液，研究考查了电流密度、循环流速、比电极面积等参数对COD去除效果的影响，分析了电化学氧化去除难降解有机物并同时脱盐的过程机理与能耗.结果表明，在电流密度32.89 mA·cm-2，循环流速0.46 cm·s-1，比电极面积65.10 m2·m-3的条件下，电化学氧化处理RO浓缩液3 h，COD去除率可达68.0%，TOC去除率可达40.6%，脱盐率可达72.1%，去除单位质量COD能耗仅为常规的板状电极电化学反应器的25.5%.本工作可为垃圾渗滤液RO浓缩液的预处理提供新思路.

English Abstract

    全文HTML

参考文献 (26)

目录

/

返回文章
返回

Copyright © 2019 中国科学院生态环境研究中心