高级搜索

废水处理生物出水中COD构成的解析 ——以焦化废水为例

,  ,  ,  ,  ,  ,  , 

downloadPDF

上一篇

下一篇

曹臣, 韦朝海, 杨清玉, 吴超飞, 吴海珍, 胡芸, 任源, 卢彬. 废水处理生物出水中COD构成的解析 ——以焦化废水为例[J]. 环境化学, 2012, 31(10): 1494-1501.
引用本文: 曹臣, 韦朝海, 杨清玉, 吴超飞, 吴海珍, 胡芸, 任源, 卢彬. 废水处理生物出水中COD构成的解析 ——以焦化废水为例[J]. 环境化学, 2012, 31(10): 1494-1501.
shu
CAO Chen, WEI Chaohai, YANG Qingyu, WU Chaofei, WU Haizhen, HU Yun, REN Yuan, LU Bin. Analysis of COD composition in biological effluent: an example from coking wastewater treatment[J]. Environmental Chemistry, 2012, 31(10): 1494-1501.
Citation: CAO Chen, WEI Chaohai, YANG Qingyu, WU Chaofei, WU Haizhen, HU Yun, REN Yuan, LU Bin. Analysis of COD composition in biological effluent: an example from coking wastewater treatment[J]. Environmental Chemistry, 2012, 31(10): 1494-1501.
shu

废水处理生物出水中COD构成的解析 ——以焦化废水为例

  • 1.

    华南理工大学环境科学与工程学院,工业聚集区污染控制与生态修复教育部重点实验室, 污染控制与生态修复广东省普通高等学校重点实验室,广州,510006;

  • 2.

    华南理工大学生物科学与工程学院,广州,510006;

  • 3.

    广州境天环保科技有限公司,广州,510640

  • 基金项目:

    国家自然科学基金重点项目(21037001)

    "十一五"国家科技支撑计划重点项目(2008BAC32B06-1)

    国家高技术研究发展计划项目(2009AA06Z319)

    华南理工大学中央高校基本科研业务经费 (2011ZP0006)资助.

Analysis of COD composition in biological effluent: an example from coking wastewater treatment

  • 1.

    The Key Lab of Pollution Control and Ecosystem Restoration in Industry Clusters, Ministry of Education, School of Environmental Science and Engineering, South China University of Technology, Guangzhou, 510006, China;

  • 2.

    School of Bioscience and Bioengineering, South China University of Technology, Guangzhou, 510006, China;

  • 3.

    Jingtian Environmental Protection Technology Co., Ltd. Guangzhou, 510640, China

  • Fund Project:

  • 摘要: 以焦化废水为例,采用连续过滤及化学分析的方法考察了悬浮组分、胶体组分及溶解组分对生物出水残余COD的贡献,并结合紫外-可见光谱和GC/MS图谱定性解析各形态组分的有机构成特征,构建了一种废水生物出水COD构成解析的评价方法.实验结果显示,焦化废水生物处理出水中悬浮态和胶体态组分对残余COD的贡献分别占COD总量的25.9%—46.3%和18.7%—44.4%,建议优先考虑采用混凝沉淀工艺去除约35.0%—45.0%的COD,使处理出水基本能够达标排放;溶解组分的COD占COD总量的24.6%—40.7%,其中4.3%—15.8%的COD由硫化物、硫氰化物等还原性物质贡献,其余部分主要由链状烃类、酯类及醇类等溶解有机组分贡献,建议采用氧化或吸附工艺进行处理,以满足更高的出水水质要求.
    Abstract: The contribution of the suspended substance, colloid and dissolved components to residual COD value in the biological effluent of coking wastewater was investigated by the methods of sequential filtration and chemical analysis. The UV-vis spectrum and GC/MS measurements were used to analyze the properties of organic compounds, aiming to establish an evaluation method for the analysis of COD composition in wastewater treatment. The results showed that the major contributions to residual COD values were suspended substance and colloid, and the ratio was 25.9%—46.3% and 18.7%—44.4%, respectively. It was indicated that about 35%—45% of the total COD from suspended and colloid components were removed by coagulation. The COD of dissolved components was 24.6%—40.7% of the total COD, and therein 4.3%—15.8% of the total COD was contributed by the reducing inorganic such as sulphide and thiocyanide. The remaining COD was contributed by chain alcohols, hydrocarbons, esters and other dissolved organic matters. Oxidation and adsorption are the suggested methods for decreasing the COD of the dissolved components in order to satisfy the higher standards. The results also provide an important theory basis for the selection of advanced treatment technologies for coking wastewater.
  • 加载中
  • [1] Barker D J, Stuckey D C. A review of soluble microbial products (SMP) in wastewater treatment systems[J]. Water Research, 1999, 33(14): 3063-3082
    [2] Lai P, Zhao H, Wang C, et al. Advanced treatment of coking wastewater by coagulation and zero-valent iron processes[J]. Journal of Hazardous Materials, 2007, 147(1/2): 232-239
    [3] Wang X, Wang L, Liu Y, et al. Ozonation pretreatment for ultrafiltration of the secondary effluent[J]. Journal of Membrane Science, 2007, 287 (6) : 187-191
    [4] Zhu X, Ni J, Lai P. Advanced treatment of biologically pretreated coking wastewater by electrochemical oxidation using boron-doped diamond electrodes[J]. Water Research, 2009, 43(6) : 4347-4355
    [5] Lu J R, Wang X L, Shan B T, et al. Analysis of chemical compositions contributable to chemical oxygen demand (COD) of oilfield produced water[J]. Chemosphere, 2006, 62(2): 322-331
    [6] Chiang P C, Chang E E, Liang C H. NOM characteristics and treatabilities of ozonation processes [J]. Chemosphere,2002,46: 929-936
    [7] Anu M, Niina L, Susanna K, et al. Removal of NOM in the different stages of the water treatment process [J]. Environment International, 2002, 28: 457-465
    [8] 张小璇, 任源, 韦朝海,等. 焦化废水生物处理尾水中残余有机污染物的活性炭吸附及其机理[J]. 环境科学学报, 2007, 27(7): 1113-1120
    [9] 帅伟, 吴艳林, 胡芸,等. 焦化废水生物处理尾水的活性炭吸附及条件优化研究[J]. 环境工程学报, 2010, 4(6): 1201-1207
    [10] Dulekgurgen E, Dogruel S, Karahan O, et al. Size distribution of wastewater COD fractions as an index for biodegradability[J]. Water Research, 2006, 40(2): 273-282
    [11] 魏复盛. 水和废水监测分析方法第四版[M]. 北京: 中国环境科学出版社, 2002
    [12] 潘霞霞, 李媛媛, 黄会静,等. 焦化废水中硫氰化物的生物降解及其与苯酚, 氨氮的交互影响[J]. 化工学报, 2009(12): 3089-3096
    [13] Barker D J, Mannucchi G A, Salvi S M L, et al. Characterisation of soluble residual chemical oxygen demand (COD) in anaerobic wastewater treatment effluents[J]. Water Research, 1999, 33(11): 2499-2510
    [14] Kuo W C, Parkin G F. Characterization of soluble microbial products from anaerobic treatment by molecular weight distribution and nickel-chelating properties[J]. Water Research, 1996, 30(4): 915-922
    [15] 胡记杰, 肖俊霞, 任源,等. 焦化废水原水中有机污染物的活性炭吸附过程解析[J]. 环境科学, 2008, 29(6): 1567-1571
    [16] Belkin S, Brenner A, Abeliovich A. Effect of inorganic constituents on chemical oxygen demand Ⅰ. Bromides are unneutralizable by mercuric sulfate complexation[J]. Water Research, 1992, 26(12): 1577-1581
    [17] Belkin S, Brenner A, Abeliovich A. Effect of inorganic constituents on chemical oxygen demand Ⅱ. Organic carbon to halogen ratios determine halogen interference[J]. Water Research, 1992, 26(12): 1583-1588
    [18] 任源, 韦朝海, 吴超飞,等. 焦化废水水质组成及其环境学与生物学特性分析[J].环境科学学报, 2007, 27(7): 1094-1100
    [19] 夏芳, 韦朝海, 吴超飞,等. H2O2/UV流化床氧化焦化废水尾水中惰性成分的可行性考察[J].化工进展, 2011, 30(5):1135-1140
  • 加载中
WeChat 点击查看大图
计量
  • 文章访问数:  1175
  • HTML全文浏览数:  1036
  • PDF下载数:  1442
  • 施引文献:  0
出版历程
  • 收稿日期:  2012-02-20
曹臣, 韦朝海, 杨清玉, 吴超飞, 吴海珍, 胡芸, 任源, 卢彬. 废水处理生物出水中COD构成的解析 ——以焦化废水为例[J]. 环境化学, 2012, 31(10): 1494-1501.
引用本文: 曹臣, 韦朝海, 杨清玉, 吴超飞, 吴海珍, 胡芸, 任源, 卢彬. 废水处理生物出水中COD构成的解析 ——以焦化废水为例[J]. 环境化学, 2012, 31(10): 1494-1501.
shu
CAO Chen, WEI Chaohai, YANG Qingyu, WU Chaofei, WU Haizhen, HU Yun, REN Yuan, LU Bin. Analysis of COD composition in biological effluent: an example from coking wastewater treatment[J]. Environmental Chemistry, 2012, 31(10): 1494-1501.
Citation: CAO Chen, WEI Chaohai, YANG Qingyu, WU Chaofei, WU Haizhen, HU Yun, REN Yuan, LU Bin. Analysis of COD composition in biological effluent: an example from coking wastewater treatment[J]. Environmental Chemistry, 2012, 31(10): 1494-1501.
shu

废水处理生物出水中COD构成的解析 ——以焦化废水为例

  • 1.  华南理工大学环境科学与工程学院,工业聚集区污染控制与生态修复教育部重点实验室, 污染控制与生态修复广东省普通高等学校重点实验室,广州,510006;
  • 2.  华南理工大学生物科学与工程学院,广州,510006;
  • 3.  广州境天环保科技有限公司,广州,510640
  • 收稿日期:  2012-02-20
基金项目:

国家自然科学基金重点项目(21037001)

"十一五"国家科技支撑计划重点项目(2008BAC32B06-1)

国家高技术研究发展计划项目(2009AA06Z319)

华南理工大学中央高校基本科研业务经费 (2011ZP0006)资助.

摘要: 以焦化废水为例,采用连续过滤及化学分析的方法考察了悬浮组分、胶体组分及溶解组分对生物出水残余COD的贡献,并结合紫外-可见光谱和GC/MS图谱定性解析各形态组分的有机构成特征,构建了一种废水生物出水COD构成解析的评价方法.实验结果显示,焦化废水生物处理出水中悬浮态和胶体态组分对残余COD的贡献分别占COD总量的25.9%—46.3%和18.7%—44.4%,建议优先考虑采用混凝沉淀工艺去除约35.0%—45.0%的COD,使处理出水基本能够达标排放;溶解组分的COD占COD总量的24.6%—40.7%,其中4.3%—15.8%的COD由硫化物、硫氰化物等还原性物质贡献,其余部分主要由链状烃类、酯类及醇类等溶解有机组分贡献,建议采用氧化或吸附工艺进行处理,以满足更高的出水水质要求.

English Abstract

    全文HTML

参考文献 (19)

返回顶部

目录

/

返回文章
返回

Copyright © 2019 中国科学院生态环境研究中心