高级搜索

聚驱污水含聚量对污水处理设备的影响

,  ,  ,  ,  ,  ,  , 

downloadPDF

上一篇

下一篇

尹先清, 张健, 靖波, 陈武, 檀国荣, 付家新, 姜维东, 朱米家. 聚驱污水含聚量对污水处理设备的影响[J]. 环境工程学报, 2012, 6(10): 3499-3502.
引用本文: 尹先清, 张健, 靖波, 陈武, 檀国荣, 付家新, 姜维东, 朱米家. 聚驱污水含聚量对污水处理设备的影响[J]. 环境工程学报, 2012, 6(10): 3499-3502.
shu
Yin Xianqing, Zhang Jian, Jing Bo, Chen Wu, Tan Guorong, Fu Jiaxin, Jiang Weidong, Zhu Mijia. Effect of polymer content of polymer-flooding sewage water on equipment for wastewater treatment[J]. Chinese Journal of Environmental Engineering, 2012, 6(10): 3499-3502.
Citation: Yin Xianqing, Zhang Jian, Jing Bo, Chen Wu, Tan Guorong, Fu Jiaxin, Jiang Weidong, Zhu Mijia. Effect of polymer content of polymer-flooding sewage water on equipment for wastewater treatment[J]. Chinese Journal of Environmental Engineering, 2012, 6(10): 3499-3502.
shu

聚驱污水含聚量对污水处理设备的影响

  • 1.

    长江大学化学与环境工程学院, 荆州434023

  • 2.

    海洋石油高效开发国家重点实验室, 北京100027

  • 3.

    中国海洋石油总公司研究总院, 北京100027

  • 基金项目:

    国家科技重大专项(2011ZX05024-004)

  • 中图分类号: TE54

Effect of polymer content of polymer-flooding sewage water on equipment for wastewater treatment

  • Fund Project:

  • 摘要: JZ9-3油田含聚采油污水粘度高、稳定性强,严重影响到现场污水处理流程和设备的运行。为解决这一问题,通过对JZ9-3油田污水处理流程和单元设备的模拟,进行了现场3种净水剂和不同含聚量的含油污水对斜管除油器、气浮选器和过滤器的影响研究。阳离子型净水剂BHQ-203和ICA的除油效果较阴离子型净水剂BHQ-08的除油效果好,能起吸附电中和及架桥作用,斜管除油器处理不同含聚含油污水后其含油量由263.2 mg/L下降到20.73 mg/L,气浮选器的除油率9%~34%,过滤器在进水含油较低(600 mg/L)后无法分析悬浮物量;斜管除油器、气浮选器和过滤器出口水样的ζ电位值在-22.5~-42 mV,随含聚量的增加而变小,污水稳定性增加。研究结果用以指导现场工艺设备的改造。
    Abstract: Produced wastewaters containing polymer,which has high viscosity and strong stability,become an obstacle to normal operating wastewater treatment and affect the normal operation of the equipment in JZ9-3 oilfield.In order to solve this problem,research is made to study the effect of three kinds of flocculants and oily wastewater with different polymer content on sloping-plate oil separation tank,air flotation device and filter by simulating treatment flow and equipment.On account of charge neutralization and adsorption bridging mechanism,oil removal effect of cationic flocculants BHQ-203 and ICA is better than anionic flocculants BHQ-08.The amount of oil content decrease from 263.2 mg/L to 20.73 mg/L after the wastewater with different polymer content is treated in sloping-plate oil separation tank,and the oil removal rate of air flotation device ranges from 9% to 34%.The oil removal effect is reinforced when the oil concentration of influent is low (＜50 mg/L).The suspended solid content decrease with the polymer concentration rising after filtering,and it is more difficult to filter.When the polymer content exceed 600 mg/L,solid content could not be analyzed.Zeta potential-22.5~-42 mV of sloping-plate oil separation tank,air flotation device,filter decrease with the polymer concentration rising,and stability of wastewater increases.The results of the research can be applied to the reformation of the technique and equipment on site.
  • 加载中
  • [1] 荆国林,于水利,韩强.聚合物驱采油污水处理技术研究进展.工业用水与废水,2004,35(2):16-18 Jing Guolin,Yu Shuili,Han Qiang.Research progress of polymer flooding wastewater treatment.Industrial Water & Wastewater,2004,35(2):16-18(in Chinese)
    [2] 马占林,陈兴原,李天德.聚合物驱采出污水深度处理的实验研究.海洋石油,2010,30(1):81-82 Ma Zhanlin,Chen Xingyuan,Li Tiande.Study on advanced produced water treatment experiments of polymer flooding.Offshore Oil,2010,30(1):81-82(in Chinese)
    [3] 刘国荣,徐群,左海强.油田含聚污水絮凝处理技术研究.流体机械,2005,33(10):8-9 Liu Guorong,Xu Qun,Zuo Haiqiang.Flocculating study of the oil-field polymer-bearing wastewater.Fluid Machinery,2005,33(10):8-9(in Chinese)
    [4] 彭齐国,车连发,宿辉.渤海绥中36-1油田核桃壳过滤器滤料清洗再生的研究.清洗世界,2007,23(9):10-16 Peng Qiguo,Che Lianfa,Su Hui.Suizhong 36-1 Oil Field,Bohai,walnut shell-filter material cleanout regenerative research.Cleaning World,2007,23(9)10-16(in chinese)
    [5] Bellagamba R.,Michaud P.A.,Comninellis Ch.,et al.Electro-combustion of polyacrylates with boron-doped diamond anodes.Electrochemistry Communications,2002,4(2):171-176
    [6] Chen Wu,Yang Changzhu,Mei Ping,et al.Electrochemical treatment of wastewater containing polyacrylamide using three dimensional electrodes.Wuhan University Journal of Natural Sciences,2007,12(2):353-360
    [7] 戚秀云,张冰,武彦辉.油田含聚污水处理技术探讨.炼油与化工,2006,17(3):45-46 Qi Xiuyun,Zhang Bing,Wu Yanhui.Research of oil-field polymer-bearing wastewater treatment.Refining and Chemical Industry,2006,17(3):45-46(in Chinese)
    [8] 刘小东,谢陈鑫.油田含聚污水的处理现状与研究进展.科技创新导报,2009,6(10):136-137 Liu Xiaodong,Xie Chenxin.Current situation and research progress of oil-field polymer-bearing wastewater treatment.Science and Technology Innovation Herald,2009,6(10):136-137(in Chinese)
    [9] 徐明进,李明远,彭勃,等.Zeta电位和界面膜强度对水包油乳状液稳定性影响.应用化学,2007,24(6):623-627 Xu Mingjin,Li Mingyuan,Peng Bo,et al.Effects of strength of interfacial film and zeta potential on oil-inwater emulsion stability.Chinese Journal of Applied Chemistry,2007,24(6):623-627(in Chinese)
    [10] 曹广胜,佟乐,胡仪,等.基于污水悬浮颗粒Zeta电位的絮凝剂用量优化.大庆石油学院学报,2009,33(1):17-20 Cao Guangsheng,Tong Le,Hu Yi,et al.Optimization of flocculant dosage by Zeta potential of the particles in sewage.Journal of Daqing Petroleum Institute,2009,33(1):17-20(in Chinese)
    [11] 王炜,封顶成.乳化油废水Zeta电位值的影响因素研究.工业用水与废水,2010,41(6):55-57 Wang Wei,Feng Dingcheng.Influencing factors of Zeta potential value of emulsified oil wastewater.Industrial Water & Wastewater,2010,41(6):55-57(in Chinese)
    [12] 万里平,孟英峰.油田作业废水絮凝过程中Zeta电位的研究.化学研究,2004,15(2):25-34 Wan Liping,Meng Yingfeng.Zeta electric potential of oilfield wastewater in flocculation process.Chemical Research,2004,15(2):25-34(in Chinese)
    [13] 吕志凤,王宗贤,何方,等.聚合物驱采油污水中乳化活性物质对污水处理的影响.石油学报(石油加工),2009,25(2):192-194 Lu Zhifeng,Wang Zongxian,He Fang,et al.Influences of emulsifying active substances on treatment of polymer-flooding produced water.Acta Petrolei (Petroleum Processing Section),2009,25(2):192-194(in Chinese)
    [14] 鞠耐霜,曾文江.阳离子型聚丙烯酰胺合成与絮凝特性研究.广州化工,2000,28(1):67-68 Ju Naishuang,Zeng Wenjiang.A study on synthesis and flocculent properties of cation-polyacrylamide.Guangzhou Chemical Industry,2000,28(1):67-68(in Chinese)
    [15] 邓述波,周抚生,陈忠喜,等.聚丙烯酰胺对聚合物驱含油污水中油珠沉降分离的影响.环境科学,2002,23(2):69-72 Deng Shubo,Zhou Fusheng,Chen Zhongxi.Effects of polyacrylamide on settling and seperation of oil droplets in polymer flooding produced water.Environmental Science,2002,23(2):69-72(in Chinese)
  • 加载中
WeChat 点击查看大图
计量
  • 文章访问数:  2553
  • HTML全文浏览数:  1625
  • PDF下载数:  1146
  • 施引文献:  0
出版历程
  • 收稿日期:  2011-08-28
  • 刊出日期:  2012-10-16
尹先清, 张健, 靖波, 陈武, 檀国荣, 付家新, 姜维东, 朱米家. 聚驱污水含聚量对污水处理设备的影响[J]. 环境工程学报, 2012, 6(10): 3499-3502.
引用本文: 尹先清, 张健, 靖波, 陈武, 檀国荣, 付家新, 姜维东, 朱米家. 聚驱污水含聚量对污水处理设备的影响[J]. 环境工程学报, 2012, 6(10): 3499-3502.
shu
Yin Xianqing, Zhang Jian, Jing Bo, Chen Wu, Tan Guorong, Fu Jiaxin, Jiang Weidong, Zhu Mijia. Effect of polymer content of polymer-flooding sewage water on equipment for wastewater treatment[J]. Chinese Journal of Environmental Engineering, 2012, 6(10): 3499-3502.
Citation: Yin Xianqing, Zhang Jian, Jing Bo, Chen Wu, Tan Guorong, Fu Jiaxin, Jiang Weidong, Zhu Mijia. Effect of polymer content of polymer-flooding sewage water on equipment for wastewater treatment[J]. Chinese Journal of Environmental Engineering, 2012, 6(10): 3499-3502.
shu

聚驱污水含聚量对污水处理设备的影响

  • 1.  长江大学化学与环境工程学院, 荆州434023
  • 2.  海洋石油高效开发国家重点实验室, 北京100027
  • 3.  中国海洋石油总公司研究总院, 北京100027
  • 收稿日期:  2011-08-28
基金项目:

国家科技重大专项(2011ZX05024-004)

摘要: JZ9-3油田含聚采油污水粘度高、稳定性强,严重影响到现场污水处理流程和设备的运行。为解决这一问题,通过对JZ9-3油田污水处理流程和单元设备的模拟,进行了现场3种净水剂和不同含聚量的含油污水对斜管除油器、气浮选器和过滤器的影响研究。阳离子型净水剂BHQ-203和ICA的除油效果较阴离子型净水剂BHQ-08的除油效果好,能起吸附电中和及架桥作用,斜管除油器处理不同含聚含油污水后其含油量由263.2 mg/L下降到20.73 mg/L,气浮选器的除油率9%~34%,过滤器在进水含油较低(600 mg/L)后无法分析悬浮物量;斜管除油器、气浮选器和过滤器出口水样的ζ电位值在-22.5~-42 mV,随含聚量的增加而变小,污水稳定性增加。研究结果用以指导现场工艺设备的改造。

English Abstract

    全文HTML

参考文献 (15)

返回顶部

目录

/

返回文章
返回

Copyright © 2019 中国科学院生态环境研究中心