高级搜索

十二烷基苯磺酸钠(SDBS)-氢氧化钠耦合污泥脱水技术研究

,  ,  ,  ,  ,  , 

downloadPDF

上一篇

下一篇

甄广印, 周海燕, 宋玉, 苏冬云, 柴晓利, 牛冬杰, 赵由才. 十二烷基苯磺酸钠(SDBS)-氢氧化钠耦合污泥脱水技术研究[J]. 环境化学, 2010, 29(6): 1106-1110.
引用本文: 甄广印, 周海燕, 宋玉, 苏冬云, 柴晓利, 牛冬杰, 赵由才. 十二烷基苯磺酸钠(SDBS)-氢氧化钠耦合污泥脱水技术研究[J]. 环境化学, 2010, 29(6): 1106-1110.
shu
ZHEN Guangyin, ZHOU Haiyan, SONG Yu, SU Dongyun, CAI Xiaoli, NIU Dongjie, ZHAO Youcai. INFLUENCE OF COMBINATION SODIUM DODECYL BENZENE SULFONATE (SDBS) AND AKALINE PRETREATMENT ON SLUDGE DEWATERABILITY[J]. Environmental Chemistry, 2010, 29(6): 1106-1110.
Citation: ZHEN Guangyin, ZHOU Haiyan, SONG Yu, SU Dongyun, CAI Xiaoli, NIU Dongjie, ZHAO Youcai. INFLUENCE OF COMBINATION SODIUM DODECYL BENZENE SULFONATE (SDBS) AND AKALINE PRETREATMENT ON SLUDGE DEWATERABILITY[J]. Environmental Chemistry, 2010, 29(6): 1106-1110.
shu

十二烷基苯磺酸钠(SDBS)-氢氧化钠耦合污泥脱水技术研究

  • 1.

    同济大学污染控制与资源化研究国家重点实验室, 上海, 200092;

  • 2.

    上海老港废弃物处置有限公司, 上海, 201302;

  • 3.

    上海同济建设有限公司, 上海, 200092

  • 基金项目:

    上海市科委2008重点项目(No.08DZ1202802)

    上海市科委2009年重大项目(No.09DZ1204105)

INFLUENCE OF COMBINATION SODIUM DODECYL BENZENE SULFONATE (SDBS) AND AKALINE PRETREATMENT ON SLUDGE DEWATERABILITY

  • 1.

    State Key Laboratory of Pollution Control and Resource Reuse, Tongji University, Shanghai, 200092, China;

  • 2.

    Shanghai Laogang Waste Treatment Co., Ltd, Shanghai, 201302, China;

  • 3.

    Shanghai Tongji Construction Co., Ltd, Shanghai, 200092, China

  • Fund Project:

  • 摘要: 研究了十二烷基苯磺酸钠(SDBS)-氢氧化钠(NaOH)耦合预处理对污泥特性的影响,分析了不同预处理条件下污泥溶解性化学需氧量(SCOD)、挥发性悬浮物(VSS)、总悬浮物(TSS)和有机酸溶出率随时间的变化规律,并进一步探讨了其对污泥脱水性能的影响.结果表明,SDBS-NaOH耦合作用时能有效地加速VSS和TSS的溶解,提高污泥水解相SCOD的浓度,当SDBS和NaOH的投加量分别为0.02g·g-1污泥(污泥干基,下同)和0.1g·g-1污泥时,VSS溶解效率高达64.0%,此时TSS含量最低,仅为23.2mg·l-1;另外,当SDBS和NaOH添加量分别为0.02和0.25g·g-1时,污泥的脱水性能良好,脱水后污泥的含水率可降到72%左右,而未预处理的污泥其含水率高达84%.
    Abstract: The influence of combination sodium dodecyl benzene sulfonate (SDBS) and alkaline (NaOH) in sludge pretreatment on sludge dewaterability was inspected, and through the changes of soluble chemical oxygen demand (SCOD), volatile suspended solid (VSS), total suspended solid (TSS) and volatile fatty acids (VFAs), the related mechanism was explored. It was found that the combination of SDBS and NaOH accelerated the solubilization of VSS and TSS, leaded in the dramatic increase in SCOD and VFAs in liquor. When the addition of SDBS and NaOH were 0.02g·g-1 sludge (dry basis) and 0.1g·g-1, respectively, the 64.0% of VSS dissolved with the lowest TSSconcentration of 23.2mg·l-1 in liquor. Furthermore, it should be pointed out that when the addition were 0.02g·g-1 and 0.25g·g-1 for SDBS and NaOH, respectively, the moisture content of dewatered sludge could reduce to approximately 72%, however corresponding 84% for unconditioned sludge.
  • 加载中
  • [1] 高健磊,闫怡新,吴建平,等. 城市污水处理厂污泥脱水性能研究[J].环境科学与技术,2008,31(2):108-111
    [2] FengXin, Deng Jinchuan, Lei Hengyi, et al. Dewaterability of waste activated sludge with ultrasound conditioning[J]. Bioresource Technology, 2009, 100:1074-1081
    [3] Watanabe Y, Kubo K,Sato S. Application of amphoteric polyelectrolytes for sludge dewatering[J]. Langmuir,1999,15:4157-4164
    [4] Lee C H, Liu J C. Sludge dewaterability and floc structure in dual polymer conditioning[J]. Advances in Environmental Research, 2001,5:129-136
    [5] Lu Ming Chun, Lin Chien Jung, et al. Dewatering of activated sludge by fenton’s reagent[J]. Advances in Environmental Research, 2003,7:667 -670
    [6] 盛宇星, 曹宏斌, 李玉平,等, 预处理对废弃活性污泥中细胞破碎和有机物质溶出的影响[J].化工学报, 2008,59(6):1496-1501
    [7] 杨虹, 王芬, 季民, 等. 超声与碱耦合作用破解剩余污泥的效能分析[J].环境污染治理技术与设备,2006,7 (5):78-81
    [8] 何玉凤, 杨凤林, 胡绍伟, 等. 碱处理促进剩余污泥高温水解的试验研究[J].环境科学,2008,29(8):2260-2265
    [9] Zhang Peng, ChenYinguang, Huang Tianyin, et al. Waste activated sludge hydrolysis and short-chain fatty acids accumulation in the presence of SDBS in semi-continuous flow reactors: Effect of solids retention time and temperature[J]. Chemical Engineering Journal,2009, 148:348-353
    [10] 杨艳, 冯晓西. 碱性环境中臭氧破解污泥的效果研究[J].环境科学与管理,2007, 32(8):101-103
    [11] 周群英, 高廷耀. 环境工程微生物学[M].北京:高等教育出版社, 2000:26-29
    [12] 王治军, 王伟. 剩余污泥的热水解试验[J].中国环境科学,2005,25(Suppl.):56-60
  • 加载中
WeChat 点击查看大图
计量
  • 文章访问数:  1421
  • HTML全文浏览数:  1302
  • PDF下载数:  644
  • 施引文献:  0
出版历程
  • 收稿日期:  2009-12-28
甄广印, 周海燕, 宋玉, 苏冬云, 柴晓利, 牛冬杰, 赵由才. 十二烷基苯磺酸钠(SDBS)-氢氧化钠耦合污泥脱水技术研究[J]. 环境化学, 2010, 29(6): 1106-1110.
引用本文: 甄广印, 周海燕, 宋玉, 苏冬云, 柴晓利, 牛冬杰, 赵由才. 十二烷基苯磺酸钠(SDBS)-氢氧化钠耦合污泥脱水技术研究[J]. 环境化学, 2010, 29(6): 1106-1110.
shu
ZHEN Guangyin, ZHOU Haiyan, SONG Yu, SU Dongyun, CAI Xiaoli, NIU Dongjie, ZHAO Youcai. INFLUENCE OF COMBINATION SODIUM DODECYL BENZENE SULFONATE (SDBS) AND AKALINE PRETREATMENT ON SLUDGE DEWATERABILITY[J]. Environmental Chemistry, 2010, 29(6): 1106-1110.
Citation: ZHEN Guangyin, ZHOU Haiyan, SONG Yu, SU Dongyun, CAI Xiaoli, NIU Dongjie, ZHAO Youcai. INFLUENCE OF COMBINATION SODIUM DODECYL BENZENE SULFONATE (SDBS) AND AKALINE PRETREATMENT ON SLUDGE DEWATERABILITY[J]. Environmental Chemistry, 2010, 29(6): 1106-1110.
shu

十二烷基苯磺酸钠(SDBS)-氢氧化钠耦合污泥脱水技术研究

  • 1.  同济大学污染控制与资源化研究国家重点实验室, 上海, 200092;
  • 2.  上海老港废弃物处置有限公司, 上海, 201302;
  • 3.  上海同济建设有限公司, 上海, 200092
  • 收稿日期:  2009-12-28
基金项目:

上海市科委2008重点项目(No.08DZ1202802)

上海市科委2009年重大项目(No.09DZ1204105)

摘要: 研究了十二烷基苯磺酸钠(SDBS)-氢氧化钠(NaOH)耦合预处理对污泥特性的影响,分析了不同预处理条件下污泥溶解性化学需氧量(SCOD)、挥发性悬浮物(VSS)、总悬浮物(TSS)和有机酸溶出率随时间的变化规律,并进一步探讨了其对污泥脱水性能的影响.结果表明,SDBS-NaOH耦合作用时能有效地加速VSS和TSS的溶解,提高污泥水解相SCOD的浓度,当SDBS和NaOH的投加量分别为0.02g·g-1污泥(污泥干基,下同)和0.1g·g-1污泥时,VSS溶解效率高达64.0%,此时TSS含量最低,仅为23.2mg·l-1;另外,当SDBS和NaOH添加量分别为0.02和0.25g·g-1时,污泥的脱水性能良好,脱水后污泥的含水率可降到72%左右,而未预处理的污泥其含水率高达84%.

English Abstract

    全文HTML

参考文献 (12)

返回顶部

目录

/

返回文章
返回

Copyright © 2019 中国科学院生态环境研究中心